| 1 | 0 | 3 | 4 | 3 | 4 |
2010 Ford F-150 repairs by problem area
Engine (24%)
Transmission and Drivetrain (19%)
Brakes and Traction Control (3%)
Suspension and Steering (9%)
Electrical and Air Conditioning (24%)
Paint, Rust, Leaks, Rattles, and Trim (19%)
Other (2%)
Chart based on 296 repairs.
2010 Ford F-150 repair cost distribution
$2500+ (4%)
$1000 - $2499 (6%)
$500 - $999 (9%)
$100 - $499 (33%)
< $100 (48%)
Chart based on 212 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2010 Ford F-150
Engine not specified
| Ford F-150 in Minnesota, United States Jul 2014 - Mar 2016 | |||
| Jul 201492000 miUS $100 | Door sensor stopped working, wouldn't autolock doors. | ||
| Mar 2016128000 miUS $10500 | Rocker arm broke and shot the piston through the engine block. Repair cost was higher than value so decided to not repair the truck. Very disappointing. | ||
2010 Ford F-150 4dr Extended Cab 8ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Ontario, Canada Sep 2012 - Dec 2013 | |||
| Dec 201376880 miC $390 | Steering shaft required replacement due to the universal seizing and locking | ||
| Ford F-150 in Ohio, United States Jun 2015 - Jun 2018 | |||
| Oct 2015189500 miUS $200 | Replace front Brake calipers | ||
| Jun 2016196000 miUS $200 | Replaced brake pads, rotors, and front left caliper. Caliper was locking up. | ||
| Jan 2017194500 miUS $75 | Replace blower motor and blower motor resistor | ||
| Mar 2017205000 miUS $50 | Loose Tie Rod. Part replaced. | ||
| May 2017207000 miUS $100 | Replaced both stabilzer bars. Ball joints were broke. | ||
| Sep 2017210000 miUS $398 | Replaced both front hubs and passenger hub actuator. | ||
| Nov 2017213600 miUS $200 | Rear end failure. Entire rear axle assembly was replaced. Replaced rear shocks. Replaced rear pads and rotors. | ||
2010 Ford F-150 4dr Extended Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in Texas, United States Jan 2015 - Dec 2015 | |||
| Mar 201552000 mi | Slip joint clunking. Repaired under warranty per Ford bulletin. | ||
| Dec 201570000 miUS $600 | Vapor canister failure followed shortly after by fuel gauge sender failure. Researched problem on the net and traded the garbage in on a new vehicle before it cost me any more money. | ||
| Ford F-150 in California, United States Jun 2010 - Jun 2022 | |||
| Dec 201124000 mi | hard downshifting water leaking from back sliding window | ||
| Aug 201236000 mi | 2 broken dash vents replaced under warranty | ||
| Feb 201456400 mi | leaking transmission fluid from rear sensor, repair at no cost due to TSB from Ford regarding this issue. | ||
| Oct 201467200 miUS $100 | motor for blending door in HVAC system rear view camera not working correctly. camera replaced | ||
| Aug 201795000 mi | Surface rust has appeared on passenger side A pillar at rooftop transition. Sub surface rust has appeared at 3rd brake light location on cab roofline. No repairs undertaken at this time. | ||
| Jan 2022125000 miUS $1800 | Had to have the roof rust (2 spots, each a 6x6 inch patch) repaired and roof and hood repainted due to clear coat issues. | ||
2010 Ford F-150 4dr Extended Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Pennsylvania, United States Jan 2015 - Jun 2018 | |||
| Sep 201589000 mi | Passenger side rearmost exhaust hanger broke. Was replaced free of charge by the shop who did the exhaust work. | ||
| Mar 201696000 mi | Passenger side rearmost exhaust hanger broke....AGAIN. Was replaced free of charge by the shop who did the exhaust work...shop relocated the hanger and installed a new one. | ||
| Ford F-150 in Iowa, United States Nov 2010 - Dec 2011 | |||
| Apr 20117800 mi | A dirty sensor in the transmission made the truck go into fail safe mode took it to the dealer it was a quick easy fix and under the warranty. Had dirty sensor in the transmission made it go into fail safe mode dealer fixed it under warranty it was quick and easy | ||
| Ford F-150 in Massachusetts, United States Jun 2012 - Jun 2022 | |||
| Oct 201241300 mi | After a heavy rain, I noticed the headliner in the cab was wet the whole width of the cab for about 2 inches forward from the rear window. Dealer says its the Upper Brake Light leaking, common problem. Not covered. Rear High Mount brakelight above the rear window leaked, dealer wouldnt cover repair under warranty. I called Ford, explained the situation and they decided to cover the repair. Replaced entire lens with new, updated unit. No issues since. | ||
| Mar 201561000 mi | Passenger side portion of rear slider window randomly shattered. No evidence of any kind of impact causing the damage. Suspect it may be from the extreme cold this winter along with use of the rear defroster frequently. Insurance covered. | ||
| Jun 201563000 mi | A heat sheild covering the driver side exhaust manifold wobbled loose and now makes a horrible vibrating noise while driving at low RPM. I put a clamp around it but it didnt hold because its so awkward and diffucult to get to this shield it | ||
| Dec 201568000 miUS $50 | Brought the truck in to have the dealer remedy the heat shield rattle, they replicated it and they were able to get two clamps around the loose shield and it did stop the rattle. Bubbles in the paint on the rocker panel below the rear door have developed. Showed to service adviser and manager at dealership. They are looking into getting this repaired/refinished under corrosion warranty. | ||
| Jan 201647500 miUS $40 | I had replaced the original serpentine belt (Motorcraft) with a new Dayco belt at 61,525 miles. It was purely preventative. The replacement belt however failed on me within 8k miles. It was a manufacturing defect. | ||
| Jun 201886050 miUS $239 | Truck exhibited a constant whining noise and slight vibration from the front end while driving. Also, engagement into 4x4 was rougher then usual and when returning to 2x4 mode, there would be heavy whining and vibration for an extended period of time. Per research on the internet, the vacuum hub actuating system was checked. Determined the actuators themselves on both the left and right side of the vehicle were at fault. Replaced with genuine Ford actuators. | ||
| Aug 201887000 miUS $18 | The lower rocker panels of the truck have significant subsurface corrosion. They are literally crumbling apart. I had purchased additional corrosion protection for the vehicle at time of purchase, went to the dealership to have this issue documented and have a claim submitted to the the third-party warranty service to see if repair will be covered under said protection plan. The plastic top portion of the engine oil dipstick seemed to have swelled with age and got stuck in the metal dipstick tube. After much effort, the dipstick was finally freed but the plastic portion was pretty mangled up. Replaced with a new one, grease will be applied to the portion that seals within the metal tube to hopefully prevent this from happening again. | ||
| Ford F-150 in New York, United States Nov 2009 - Dec 2016 | |||
| Jun 201220000 mi | Replaced leaking A/C condensor | ||
| Ford F-150 in New Mexico, United States Mar 2010 - Dec 2015 | |||
| Feb 201112500 mi | SYNC system microphone relocated per TSB | ||
| Jan 201213000 miUS $200 | Sync problem regulating volume between phone and music modes. After much fumbling the truck was scheduled for a follow-on software upgrade - the problem is still there. non-working bracket for d/s visor. fixed | ||
| Jul 201335500 miUS $150 | solenoid for engaging/disengaging 4wd failed | ||
| Feb 201443400 miUS $700 | leaking gasket | ||
| Dec 201453000 miUS $120 | fluid leak-2nd repair in 3 months. not successful. will return to shop | ||
| Jan 201544300 miUS $300 | Bulkhead connector o-ring failure. This was the source of the trans leak that the repair shop misdiagnosed. I looked-up the symptoms on the web and this seemed the most likely problem. It has fixed the problem. | ||
| Ford F-150 in Michigan, United States Sep 2011 - Sep 2014 | |||
| Sep 201214000 mi | Window track was loose within passenger door. Dealer tightened things up, rattle was repaired. | ||
| Ford F-150 in Pennsylvania, United States Aug 2014 - Aug 2015 | |||
| Aug 201443000 mi | Torsion bar in tail gate failed again. Replaced second time under warranty. | ||
| Nov 201445100 miUS $5 | Gas lid hinge worn. Drilled a hole in the bottom of the hinge pin and inserted a cotter pin to prevent hinge pin from falling out. Symptom was gas lid that wouldn't close. | ||
| Aug 201552000 miUS $40 | A/C Compressor clutch rubber damper melted. Replaced part with identical new part. | ||
| Ford F-150 in Minnesota, United States May 2010 - Sep 2017 | |||
| Jan 201371000 miUS $170 | Power steering hose exploded. Replaced hose and flushed power steering fluid. Required 2 trips because they did not flush the fluid the first time. | ||
| Dec 201396000 miUS $760 | Power steering hose was blowing open when starting up in very cold weather. The AC condenser was replaced, as the fluid could not move through it. | ||
| Sep 2014120000 mi | Replaced Tie rod | ||
| Nov 2014123400 miUS $600 | Need to flush transmission fluid. But the plug had dipstick broken off, and the connection was leaking. | ||
| Ford F-150 in Nuevo Leon, Mexico Mar 2011 - Jan 2022 | |||
| Apr 2017136400 mi$4200 | Suddenly a valve has been broken and as we did't know how much damage it make's I prefer to change all the engine for a newer. I found a 38,000 miles Expedition motor and the mechanic make the installation. | ||
| Mar 2018142600 mi$200 | Overheat while idle more than 1 hour at 100F or above. One of the radiator (right side) fan doesn't work properly changed by afternarket motor and recharge gas at 245,000kms | ||
| Ford F-150 in Pennsylvania, United States Dec 2009 - Dec 2011 | |||
| Nov 20107100 mi | Transmission vibration between gear shifts (automatic trans) Wanted TSB For SNYC microphone taken care of. They refused to repair | ||
2010 Ford F-150 4dr Extended Cab 6.5ft bed
292-horsepower 4.6L V8 6-speed automatic RWD
| Ford F-150 in Indiana, United States Feb 2015 - Dec 2022 | |||
| Jan 2018126000 miUS $24 | Climate temperature actuator not working in cold weather (0 F degrees). Ordered new actuator. | ||
2010 Ford F-150 4dr Extended Cab 6.5ft bed
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in British Columbia, Canada Jul 2010 - Feb 2014 | |||
| Sep 20107440 mi | squeal when rolling window down. window channels lubed | ||
| Oct 20107440 mi | Squeaking Passenger Side Window again after about a week-and-a-half. Fixed with lube. | ||
| Sep 201121080 mi | foam lining where glass meets dash popped out, parts ordered | ||
| Apr 201335960 mi | Water leak found from exterior brake/reverse light as well as satellite antenna -> Fixed under warranty | ||
| Aug 201341540 mi | Front Passenger side window was making squeaky noise | ||
| Ford F-150 in Iowa, United States Apr 2017 - Jun 2018 | |||
| Oct 201779000 miUS $56 | Replaced the Evap canister purge valve. It was causing a Check Fuel Inlet light. | ||
| May 201893000 miUS $100 | The check engine light came on. Circuit board in PCM was corroded. Repaired by the dealer. Took less than 2 hours. The dealer saved me a lot of money by splicing the connections instead of replacing the PCM. | ||
| Ford F-150 in Virginia, United States Feb 2010 - Jan 2022 | |||
| Jul 201565300 miUS $40 | Limited slip differential continues to cause vibration when accelerating from a turn. Replaced the fluid and added friction modifier per previous recommendation from dealer. Unfortunately problem persists. | ||
| Ford F-150 in Missouri, United States Oct 2010 - Jun 2013 | |||
| Nov 20102900 mi | Replace rear shocks due to clunking noise Replace rear shocks due to clunking noise | ||
| Jun 201117000 mi | Truck was having a slight miss under load. Dealer replaced throttle body. | ||
| Dec 201251000 mi | Fluid leak from a transfer tube, per the work order. | ||
| Ford F-150 in Massachusetts, United States Sep 2010 - Jun 2018 | |||
| Mar 201111000 mi | Leaking satellite anteana during heavy rain. TSB for this. Loose foam strip between dash and wind shield | ||
| Ford F-150 in Michigan, United States Apr 2018 - Jul 2022 | |||
| Jun 202011500 miUS $350 | front end shimmy and clunking noise on passenger side - replaced front struts and springs, lower control arms and rear shocks. | ||
| Nov 2020118000 miUS $1800 | R&R Exhaust Manifolds both sides | ||
| Mar 2021123000 miUS $3500 | replaced driver and passenger rear wheel patches, cab corners, rocker panels - Paint affected areas | ||
| Oct 2021130000 miUS $300 | Brakes were not working well and squishy. gas mileage had dropped and it felt like the brakes were dragging - replaced driver side rear caliper, rebuilt calipers on front to fix seized caliper pins. replaced pads on front and rear, replaced front rotors. | ||
| Nov 2021130000 miUS $275 | grinding noise when engaging the 4x4 - replace passenger side actuator | ||
| Jun 2022132000 mi | poor fuel economy and weak heater. Replaced thermostat gained 3 mph | ||
| Jul 2022135000 miUS $250 | leaking anti-freeze. Replaced the water pump | ||
2010 Ford F-150 4dr Extended Cab 5.5ft bed
411-horsepower 6.2L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Michigan, United States Dec 2010 - Dec 2015 | |||
| Nov 201477800 miUS $50 | Heated Seat Broke | ||
| Oct 201596000 miUS $50 | Solenoid replaced | ||
| Ford F-150 in Rhode Island, United States Nov 2010 - Jun 2022 | |||
| Dec 201342000 miUS $100 | clock winder affecting horn and cruise control. repaired under extended warrantee, deductible applied | ||
| Jun 201448000 mi | driver and passenger cv leaking. dealer replaced driver side under warranty but manufacturer would not approve passenger side repair. two weeks later the passenger side failed and was then replaced under warranty | ||
| Feb 201672600 miUS $200 | replace worn tie rods | ||
| Dec 201682000 mi | navigation system not functioning properly | ||
| Jan 2022136000 miUS $2300 | replaced entire under dash system | ||
| Feb 2022136000 miUS $1500 | replaced all in dash components, the first repair was not properly done by another shop | ||
2010 Ford F-150 4dr Extended Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Colorado, United States Dec 2016 - Sep 2018 | |||
| Mar 2017114000 miUS $70 | Replaced sway bar end links | ||
| Apr 2018126000 miUS $500 | All 4 shocks were leaking again. I rebuilt them myself this time. | ||
| Sep 2018130000 miUS $21 | Passenger side blend door failed. I replaced it very easily and cheaply. | ||
| Ford F-150 in Virginia, United States Jan 2012 - Jul 2015 | |||
| Oct 201222500 mi | Third brake light water intrusion. | ||
2010 Ford F-150 4dr Crew Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in North Carolina, United States Aug 2013 - Aug 2014 | |||
| Aug 2014125000 miUS $1100 | Blend Door actuator needed to be replaced | ||
| Ford F-150 in Alabama, United States Feb 2011 - Apr 2015 | |||
| Mar 201383000 miUS $200 | Driver seat heater stopped working | ||
| Aug 2014119300 miUS $100 | Sliding window seal had come loose; dealer reinstalled | ||
2010 Ford F-150 4dr Crew Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Oregon, United States Jan 2012 - Feb 2012 | |||
| Feb 20129000 mi | Fuel pump failure, Vehicle stalled on incline with 1/4 tank of gas | ||
| Ford F-150 in North Carolina, United States Feb 2011 - Apr 2012 | |||
| Mar 201127000 mi | Tranny shifted hard 1-2 gear.common problem improved by updated program but not erased. | ||
| Jun 201136000 mi | Also drivers window was lubricated to eliminate squeaking noise when putting down window. | ||
| Ford F-150 in Colorado, United States Jan 2011 - Jun 2018 | |||
| Jan 201531200 miUS $1000 | Bad bearing in driveshaft. Replaced the driveshaft. Broken vacuum harness that controls the automatic locking hubs for the 4wd. Replaced harnesses and hubs. It appears that the vacuum harnesses was broken by an oil change shop when they were checking the fluid in the front differential. | ||
| Oct 201567200 miUS $18 | Driver's side sun visor retention clip broke and needed to be replaced. | ||
| Nov 201678800 miUS $425 | Passenger mixer door actuator broken. No temperature control for passenger heat. | ||
| Jun 201892000 miUS $72 | AC coolant was low. No leaks found. TPS sensor in one tire failed. Needed replacement. | ||
| Ford F-150 in Wisconsin, United States Oct 2010 - Apr 2014 | |||
| Nov 20104000 mi | Check engine light came on at mileage 3665. Was checked at dealer and code P2096 00.68 was given. This code does not exist. Was told there was a bulletin on this problem. Computer was reset per ford's recomendation. | ||
| Dec 20104000 mi | Check engine light came on again. Code was ran and was told that I needed to replace an o2 sensor. O2 sensor was ordered. Also had an oil change and tires rotated at this appt. O2 sensor replaced. Codes in computer were p02270. H025 connector was also found to be out of spec and was repaired. | ||
| Ford F-150 in Alberta, Canada Dec 2010 - Apr 2011 | |||
| Apr 20115580 mi | Reflash transmission and replaced mechatronic | ||
| Ford F-150 in New York, United States Sep 2010 - Jul 2022 | |||
| Mar 201121000 mi | Power running board motor was seized - dealer replaced motor under warranty. | ||
| Oct 201137000 miUS $100 | Passenger side climate control blew out hot air regardless of temperature setting - AC blend controller and blend door motor on passenger side were both replaced | ||
| Dec 201265000 miUS $100 | Motor for driver's side power mirror malfunctioned - replaced mirror assembly | ||
| Jun 2014102000 miUS $100 | Climate control blender motor was replaced. | ||
| Mar 2016124000 miUS $1200 | High pressure line to power steering pump leaking Power running boards not retracting fully Oil pan was rusting thru, oil was weeping out of the bottom. Since this was rust perforation, extended warranty didn't cover replacement. | ||
| Jul 2022204000 miUS $287 | Low refrigerant; refilled and added dye to check for subsequent leaks | ||
| Ford F-150 in Washington, United States Mar 2011 - Jan 2017 | |||
| Dec 201229000 mi | Cab heater blend door actuator was faulty, warranty fix, no questions asked. | ||
| Jan 2017US $100 | Navigation system antenna failed | ||
| Ford F-150 in Quebec, Canada Mar 2012 - Oct 2012 | |||
| Apr 201216520 mi | Shifting from 1st to 2nd (and 2nd to 1st)is hard. Was due to lack of grease in the universal joint between the two parts of driving shaft. Dark spot behind mirror surface | ||
| Ford F-150 in Ontario, Canada Jan 2011 - Jun 2022 | |||
| May 201115500 miC $125 | Complained of vibration between 50-60 mph. Dealer balanced all tires and replaced 1 tire that was out of spec. | ||
| Jul 201118600 mi | Replaced rear differential clutch pack due to excessive grab when cornering. | ||
| May 201236580 miC $1250 | Front speakers cutting out intermittently. Dealer replaced both front speakers but problem continued. On third visit, dealer replaced wiring harness. No issues since. | ||
| Aug 201349600 mi | Vibration between 80-120 kph. Driveshaft was observed to be vibrating. Driveshaft replaced under warranty. Vibration solved. | ||
| Jul 201459180 mi | Broken exhaust manifold studs due to warped manifold. Dealer replaced passenger-side manifold & studs under warranty. | ||
| Oct 201463020 mi | Exhaust noise under load. Broken exhaust manifold studs on driver side. Dealer changed driver-side manifold and studs. | ||
| Jan 201894860 miC $200 | Upper and lower ball joints | ||
| Jun 201899820 miC $185 | Water accumulating in headlight | ||
| Jun 2019112220 miC $125 | Right exhaust manifold leaking. | ||
| Apr 2021130200 miC $138 | Right Exhaust manifold leak | ||
| Ford F-150 in Washington, United States May 2010 - Apr 2015 | |||
| Oct 201012000 mi | Passenger front window quit working after multiple uses in hot weather, then resumed working in a few minutes. Could not replicate for dealer. Front passenger seat controls for A/C and Heating quit working one time. Could not repeat or replicate. | ||
| Apr 201224000 mi | Water leak in back seat. Dealer replaced roof brake light housing to repair. The shiny coating on the sliding rear window gasket was deteriorating and left an area about two inches long showing rough rubber. After photographing it and sending it to Ford, they elected to replace the entire rear window. Installed new window. | ||
| May 201450900 miUS $50 | A/C Fan quit working | ||
| Ford F-150 in Idaho, United States Sep 2016 - Mar 2018 | |||
| Nov 201642500 mi | Tsb performed to lube the two piece driveshaft slip joints to eliminate clunk on takeoff. | ||
| Mar 201745000 miUS $150 | Replaced spark plugs and coil packs, preventative maintenance | ||
| Ford F-150 in Alberta, Canada Sep 2016 - Mar 2018 | |||
| Feb 201779100 mi | cv boot replaced on the front driver side. | ||
| Mar 201779980 mi | A rubbing sound from the passenger side occurred after having a cv boot replaced on the front driver side. The intermittent sound went back to the shop twice. Originally I thought the sound had come from repair on the cv boot but the shop thought otherwise. They change the bearing but the sound returned. The sound appeared to disappear when you engaged the four wheel drive. In the end it was determined that when the shop did the cv boot they inadvertently broke the seal on the four wheel drive system on the passenger side. No cost to me to fix the seal as it was their error. | ||
| Ford F-150 in Oklahoma, United States Feb 2010 - Apr 2012 | |||
| Mar 20104000 mi | Thin paint on left side. Both doors and bed repainted on drivers side | ||
| Ford F-150 in North Dakota, United States Dec 2014 - Jun 2022 | |||
| Jan 2018195500 mi | Cylinder #8 missfire, replaced #8 spark plug and coil. Cyliner #8 still missfires, in particular on startup. Rotated fuel injectors #8 with #4, checked the codes. | ||
| Mar 2018238000 miUS $3000 | I replaced the engine with a used engine that I purchased on line from a place in Florida. The engine I bought came out of a Lincoln Navigator, it had 57k miles on it. I have had the vehicle back now for about 10 days and I have put about 4 thousand miles on it. It seems to run just fine. | ||
2010 Ford F-150 4dr Crew Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in Florida, United States Jul 2010 - Dec 2011 | |||
| Sep 20105000 mi | Vibration at highway speed. Differential was re aligned | ||
| Ford F-150 in Kentucky, United States Jul 2013 - Aug 2016 | |||
| Aug 201374000 mi | replaced center driveshaft boot and regreased spline | ||
| Ford F-150 in Texas, United States Jul 2013 - Dec 2019 | |||
| Oct 201358000 mi | Heater vent controls stopped working. Only blowing cold air | ||
| Mar 201585000 mi | REPLACED THERMOSTAT AND CLEARED ERROR CODE | ||
| Ford F-150 in Louisiana, United States Jul 2010 - Nov 2011 | |||
| Nov 201119000 mi | I had no repairs, but one of the releases on the bottom of the rear seats broke just before I traded it in. This latch allowed the release that let the seats back down. | ||
| Ford F-150 in Texas, United States Feb 2011 - Jun 2016 | |||
| Mar 201218000 mi | Lubricated CV | ||
| Ford F-150 in Texas, United States Nov 2014 - Jun 2018 | |||
| Oct 2015107200 miUS $192 | replaced original battery, battery failed | ||
| Sep 2017130000 mi | truck went to limp mode while driving and got engine check light. shut truck down, after 5 minutes limp mode cleared. read code for check light , had issue with transmission solenoid. cleared code has not re lit believe it was a short. | ||
| Ford F-150 in Texas, United States Sep 2009 - Jul 2017 | |||
| Jul 20118200 mi | Check A/C - Doesn't cool good, never has. I sweat in the Ford for 15 or 20 minutes before it cools enough to be comfortable. Ford says it's working fine. My Chevy much better, has to have blower reduced by the end of my 2 mile road or you will freeze. Low Fuel Mileage, down to a steady 16mpg from 19. | ||
2010 Ford F-150 4dr Crew Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Texas, United States Aug 2010 - Jun 2022 | |||
| May 20102500 mi | Passenger seat heater would not work, resulted in entire cab wiring harness being replaced. Repaired under warranty. | ||
| Jun 20103000 mi | Sun visor retaining clips distorted and would no longer keep visors in place. | ||
| Aug 201325100 miUS $250 | 3rd brake light / cargo light leaks water down back window during heavy rains. | ||
| Feb 201645100 miUS $800 | Power steering cooler leak. | ||
| Mar 201646000 miUS $600 | Blend motor failed | ||
| Dec 201656000 miUS $250 | 3rd brake light was allowing water to leak into the interior. Leak was fixed. | ||
| May 202290000 miUS $300 | Replaced leaking sensor connector. | ||
| Ford F-150 in North Dakota, United States Jan 2010 - Sep 2012 | |||
| Nov 201010000 mi | The rear end has a hop on concrete roads that is more than annoying. The hop drives up into the cab and is very noticeable when driving at speeds over 55. This is a common problem with Ford F150's that is being ignored by Ford Motor. | ||
| Ford F-150 in Ontario, Canada Aug 2010 - Dec 2014 | |||
| Apr 201221280 mi | Leaking shock replaced rear left. | ||
| Ford F-150 in Missouri, United States Dec 2009 - Sep 2012 | |||
| Sep 201114000 mi | Transmission shifting problem corrected with ECU reflash per TSB. Phone calls through Sync System are not heard very well by receiving party. Dealer could not duplicate. | ||
| Ford F-150 in Florida, United States Jun 2010 - Feb 2015 | |||
| Oct 201338300 mi | Rear O2 Sensor Repaced | ||
| Aug 201442300 mi | Torque Converter Shutter | ||
| Ford F-150 in Alberta, Canada Jun 2010 - Aug 2020 | |||
| Jun 201554560 miC $2500 | Warped exhaust headers Air compressor failed | ||
| Ford F-150 in Manitoba, Canada Jun 2010 - Sep 2011 | |||
| May 201114260 mi | Strong wind noise on drivers side door since new. Ended up being a cracked rain gutter at top of door. Once identified, repair done and it's fine. | ||
| Ford F-150 in Colorado, United States Jan 2010 - Jun 2018 | |||
| Mar 201233000 mi | Actuator failed - front passenger side blew hot air regardless of climate setting | ||
| Apr 201473500 mi | Doors and tailgate paint is bubbling from beneath. | ||
| Dec 201488000 mi | power deployable running board motor failed | ||
| Jul 2016107500 miUS $500 | Intermittent check engine light leaking front strut | ||
| Ford F-150 in Utah, United States Jun 2010 - Mar 2017 | |||
| Jul 201223300 mi | Driver seat retracting feature was noisy during operation. | ||
| Ford F-150 in California, United States Mar 2010 - Jun 2022 | |||
| Jun 201132000 miUS $10 | the receiver end of sun visor broke so i had to purchase another one and luckily the part was in stock | ||
| Nov 201256200 miUS $50 | The gas door hinge spring broke so door would not stay shut. I bought new hinge with spring and it was installed in 15 minutes. | ||
| Jul 201366700 miUS $170 | The right rear shock was bent and was replaced with a new shock | ||
| Ford F-150 in Colorado, United States Mar 2011 - Jan 2017 | |||
| Jan 201751000 miUS $374 | Replaced leaking radiator | ||
| Ford F-150 in Michigan, United States Apr 2016 - Jun 2022 | |||
| Jul 201656700 miUS $850 | replaced compressor and some related parts, | ||
| Feb 201769000 miUS $600 | brake pad wore out due to frozen caliper. One caliber, both rotors and both pads replaced. | ||
| Jun 201775000 mi | AC went out. Bad compressor under warranty from June 2016. Shop did not charge me. | ||
| Jun 201885000 miUS $900 | had a bad circuit for the fuel pump causing the fuse to blow. known issue to dealer. had to had a circuit to the fuse box for the fuel pump. | ||
| Jun 2022115000 miUS $500 | Replaced trans pan seal, filter and fluid. | ||
| Ford F-150 in New Jersey, United States Jan 2015 - Dec 2016 | |||
| Sep 201684000 miUS $800 | Replaced left exhaust manifold | ||
| Ford F-150 in Ontario, Canada Sep 2014 - Jul 2018 | |||
| Oct 2015119040 miC $2500 | Both exhaust manifolds warped and leaking, replaced. Back up camera failed, replaced. | ||
| Jun 2018175460 miC $2000 | Replaced warped exhaust manifolds again. Parts under warranty, paid for labour. Repaired corroded electrical wires controlling rear windows and locks. Rust under doors and in back corner of cab. Quoted $3000 to repair but unsure if I should just run vehicle and let it rust. | ||
| Ford F-150 in Manitoba, Canada Dec 2015 - Mar 2018 | |||
| Jan 201620560 mi | Alternator bearings scream when cold. Dealer states no problem, they all do it. Corrosion in the wheels mounting area on three wheels. Dealer acknowledged problem due to manufacturing error with no finish in area of corrosion. Ford Mo Co blamed owner and denied claim. Dealer had wheels refinished on their tab. | ||
| Feb 201620960 mi | Door speakers cutting out. They have already been repaired/replaced on three other occasions. Dealer said unable to replicate. | ||
| Sep 201622940 mi | Best fuel mileage able to achieve was 15L/100 Klm. Dealer said had to document over 2 full tanks of fuel but didn't think they could do anything. This is no where near figures from Ford for this vehicle. | ||
| Nov 201623340 mi | Front struts are leaking. Rear shocks have already been replaced under warranty for same problem. | ||
| Ford F-150 in Arkansas, United States Apr 2016 - Jun 2017 | |||
| Jan 201767000 mi | Transmission fluid Leak | ||
| Ford F-150 in Ontario, Canada Sep 2017 - Jul 2024 | |||
| Dec 201791760 miC $156 | The driveshaft going into the transfer case was dry causing a ‘slip-bump’ when coming to and leaving from a full stop | ||
| Ford F-150 in Iowa, United States Jan 2021 - Jun 2022 | |||
| May 202197000 miUS $300 | Steering gear was corroded, very hard to turn the wheel | ||
| Ford F-150 in Ontario, Canada Mar 2014 - Jun 2018 | |||
| Jan 201884196 miC $230 | CEL came on and after scanning the code (P0130) found the upstream O2 sensor (between cat and manifold) on passenger side failed. Replaced the sensor (DY-1165) myself. No more CEL :) | ||
| Ford F-150 in Florida, United States Jul 2017 - Jun 2018 | |||
| Dec 2017110000 miUS $155 | Accessory belt, idler pulleys, and tensioner. Tensioner and one idler pulley showed signs of the belt skidding on the pulley. Replaced others as precaution. Belt didn't need replacing but did it anyway. | ||
| Mar 2018111000 miUS $150 | Replaced right side manifold due to crack. Used cast iron replacement part. | ||
| Ford F-150 in Nebraska, United States Jun 2013 - Jul 2018 | |||
| Feb 201674000 miUS $100 | Electric harness for driver side rear door broke that prohibited me from electronically locking and unlocking the door. | ||
| Ford F-150 in Utah, United States Feb 2013 - May 2015 | |||
| Jun 201353000 miUS $100 | Driver side vents were blowing hot air while passenger side vents blew cold while running AC. Left side TEMP ACTUATOR replaced. AL3Z 19E616 A: MOTOR ASSEMBLY | ||
| Jan 201456900 miUS $100 | This time it was the passenger side that was stuck on heat no matter what temperature setting was dialed in. Diverter box on that side was stuck to full heat. | ||
| Ford F-150 in California, United States Dec 2010 - Sep 2014 | |||
| Mar 201217000 mi | Fuel filler door came off of its hinge. Dealer had to take it out and reset it onto the hinge. | ||
| Feb 201444000 miUS $700 | 1 leaking rear shock and 1 leaking front strut. Ended up replacing all 4 out of pocket as factory warranty had expired 8k miles ago | ||
| Ford F-150 in Minnesota, United States Mar 2010 - Sep 2012 | |||
| Sep 20105705 mi | Reflashed the transmission control module memory. Reflashed the transmission control module memory. | ||
| Apr 201222000 mi | Oil leaking at output shaft seal for rear driveshaft. Remove driveshaft and install new seal | ||
| Ford F-150 in New Hampshire, United States Oct 2010 - Sep 2011 | |||
| Jan 2011 | Weatherstripping on rear doors was defective causing wind noise. Replaced under warranty. When key is removed from ignition the chime would still ding like the key was still in the ignition and easy exit feature did not work. Problem was intermittent. Dealer could not replicate. Dealer lubricated key slot. | ||
| May 20114500 mi | Transmission was shifting hard. Dealer reprogrammed computer. Wind noise on highway. Dealer adjusted doors. Front passenger seat squeaks over bum | ||
| Sep 20117000 mi | Glass in front of speedometer was scratched. Dealer stated ford would not repair. They did admit that it should not scratch that easily. | ||
| Ford F-150 in Minnesota, United States Oct 2010 - Jun 2011 | |||
| Feb 201118000 mi | Took truck in to the dealer for oil change and tire rotation. Mechanic discovered a slight leak at the pinion seal. Scheduled a time for repair the following week. Pinion seal was replaced. | ||
| Ford F-150 in Oregon, United States Nov 2010 - Jun 2015 | |||
| Mar 20113000 mi | hard dowshift from 2-1, shop did a reflash of transmission module | ||
| Ford F-150 in Minnesota, United States Oct 2009 - Jun 2013 | |||
| Oct 20107200 mi | Control switch for heater/air conditioner fan replaced | ||
| Ford F-150 in Iowa, United States Mar 2013 - Mar 2015 | |||
| Jun 201347000 miUS $500 | A/C quit working. Hole in the condenser. New condenser installed system re-charged. Everything OK. Aluminum condenser not very tough. | ||
| Ford F-150 in Minnesota, United States Dec 2012 - Jun 2014 | |||
| Sep 201343000 mi | The drivers side speaker kept cutting out. The dealer never fixed it correctly even after two more attempts at getting it right. I finally fixed it right myself and now there's no more issues with my speakers. | ||
| Ford F-150 in Arizona, United States Apr 2012 - Jun 2022 | |||
| Feb 201216000 mi | Serpentine belt snapped and broke off the power steering pump in the process. | ||
| Mar 201328000 mi | None of the rear lights working. | ||
| Mar 201763000 mi | Transmission shifting hard around 40mph, fixed per Ford TSB. Software update, no charge. | ||
| Ford F-150 in Wisconsin, United States Sep 2010 - Aug 2016 | |||
| Jun 201111000 mi | Minor water leak from roof mounted satellite antenna. Dealer followed TSB to repair leak using RTV silicone. | ||
| Jul 201339300 miUS $140 | Service noticed unusual wear on ujoint at previous oil/filter service. U-Joint wearing abnromally and needed to be replaced. | ||
| Jun 201452000 miUS $96 | Heat shield clamp broke causing a harmonic vibration under cab at idle and at 37 mph. | ||
| Ford F-150 in Ontario, Canada Mar 2010 - Jun 2011 | |||
| Apr 20101240 mi | Split in seam of leather upholstery Split in seam of leather upholstery - incorrect part ordered | ||
| May 20101240 mi | Split in seam of leather upholstery, part replaced | ||
| Ford F-150 in Arizona, United States Aug 2009 - Nov 2018 | |||
| Jul 20109000 mi | Transmission 1-2 upshift harshness fixed with reflash. Sync reflashed. Latch on center console replaced as it would not latch. | ||
| Nov 201014000 mi | A/C not working well. By comparing high pressure readings against a new vehicle on the lot it was determined that a reflash of the PCM would remedy the situation. According to dealership, A/C pressures were the same following the reflash. It was determined that a front strut was leaking and not assembled correctly at the factory. A new strut and related hardware were ordered. Parts arrived (after dealer verified owner's observation of a leaking and misassembled front strut assembly on previous visit) and were installed at this time. | ||
| Jun 201235000 mi | Despite a PCM reflash in 2010, the AC still was "underperforming" when temps exceeded 95 degrees. Tech found a later reflash which improved AC function to be more in line with what it should have been (41 degree discharge air/105 ambient). | ||
| Jan 201310200 miUS $90 | Took in for wheel alignment prior to installing new tires. Mechanic noticed battery was cranking slowly, suggested replacing soon. Battery replaced by owner with Interstate battery from Costco. | ||
| Mar 201682000 miUS $380 | A "bulkhead" connector developed a leak necessitating removal of the pan, to access the offending part. Parts included connector, pan gasket, replacement transmission fluid. | ||
| Jun 201793000 miUS $305 | Replaced sun-deteriorated Urethane steering wheel with new leather steering wheel. | ||
| Ford F-150 in Michigan, United States Oct 2009 - May 2014 | |||
| Dec 20091000 mi | doors kept locking and unlocking - loose connection between door and cab. Connection had not seated properly. | ||
| Jan 201045300 mi | Keyless entry key pad had a stuck button and the unit shorted out. Truck acted like it had a mind of its own locking and unlocking the doors. | ||
2010 Ford F-150 4dr Crew Cab 5.5ft bed
292-horsepower 4.6L V8 6-speed automatic RWD
| Ford F-150 in Texas, United States Jun 2014 - Jan 2015 | |||
| Jun 201468000 miUS $30 | Driveshaft acting like it had slack in it | ||
| Sep 201481000 mi | Again driveshaft acting like it had slack in it and it was lubed again | ||
| Jan 2015 | Again the drive shaft ia acting like it has slack in it. I'm sure they will say it needs to be lubed with a special lube that onkly Ford has. This seems to be a problem in the 2010-2011's | ||
| Ford F-150 in Oklahoma, United States Aug 2013 - Apr 2015 | |||
| Oct 201317300 miUS $148 | Original battery had a bad cell. Replaced with Ford BXT-65-750 which is an upgrade from 650 cranking amps battery on the original. | ||
| Ford F-150 in Texas, United States Nov 2011 - Nov 2012 | |||
| Mar 201249000 miUS $450 | third brake light leak, fomoco paid half out of warranty cost | ||
| Ford F-150 in California, United States Sep 2010 - Jan 2020 | |||
| Jul 201342500 miUS $300 | Dealer could not duplicate; test drove truck with diagnostic computer, no concerns noted; downloaded/installed latest PCM calibration. Would have cost $300 if didn't have maintenance contract. | ||
| Dec 201349000 mi | Same as last reported issue. While decelerating from freeway speeds, engine would run very rough and then die when truck came to complete stop. Dealer replaced throttle body, flashed the ECM, and replaced the torque converter (for same problem). | ||
| Aug 201571000 mi | Poor gas mileage. MPG down to 15mpg vs 17mpg over the previous 5 years | ||
| Dec 201683000 miUS $550 | Transmission pan gasket was leaking and was replaced. Transmission bulb head connector was leaking and gasket was replaced. | ||
| Ford F-150 in Mississippi, United States Jun 2010 - Feb 2013 | |||
| Jan 20115000 mi | Harsh shift from 2nd to 1st when coming to stop at slow speed. Reflashed PCM/TCM to correct the issue. | ||
| Ford F-150 in Tennessee, United States Jun 2010 - Jun 2012 | |||
| Feb 20118000 mi | Two piece driveshaft free play causing clunk on downshifts and "slipping feeling" on takeoff from stop. Dealer lubed connecting shafts and put 2 clamps on the shafts. Fix may or may not hold up over time | ||
| Jun 201224000 mi | Install shim kit to correct driveshaft angle. All warranty work. Also the slip yoke was again lubed with heavy grease to eliminate the "slip-bump" on take off. | ||
| Ford F-150 in Washington, United States Oct 2015 - Sep 2021 | |||
| Dec 201548000 miUS $645 | Cluster replace | ||
| Apr 201649000 miUS $26 | Regrease yolk joint to prevent binding. Sometimes needs replacement of the yoke with a chrome one (in the spline area). Dealer quoted $295. | ||
| Ford F-150 in Oklahoma, United States Aug 2016 - Sep 2020 | |||
| Sep 2016127000 miUS $54 | Replaced canister purge valve silenoid. | ||
| Ford F-150 in Texas, United States Jun 2019 - Jun 2022 | |||
| Jun 2019110000 miUS $1200 | New Radiator and flush cooling system | ||
| Aug 2019115000 miUS $400 | New Rotors and Pads on Front and Rear | ||
| Feb 2020120000 miUS $325 | Replace Steering Wheel - Cover coming off | ||
2010 Ford F-150 4dr Crew Cab 5.5ft bed
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Connecticut, United States Jan 2016 - Jul 2022 | |||
| Jul 2022148000 miUS $500 | Alternator failed | ||
| Ford F-150 in Illinois, United States Feb 2013 - Jan 2022 | |||
| May 201441000 miUS $305 | The purge valve on the evaportative canister was replaced as related to TSB 11-1-5. Truck had rough idle, stalled twice while driving, and hard start condition after fueling. | ||
| Apr 201682800 miUS $4500 | Transmission failed. Lost 5th gear and metal throughout. Took to dealer hoping Ford would help with the cost of the repair. After 12 days, Ford said no help. Now at trans shop waiting for re-manufactured transmission to be installed. | ||
| Oct 2017117000 miUS $425 | Had 2 pulleys go bad. The tensioner pulley and the center ribbed pulley. Also replaced the Serpentine belt. The pulleys had been making noise for months, and thought it was the power steering pump. | ||
| Ford F-150 in Wisconsin, United States Nov 2010 - Aug 2013 | |||
| Dec 20101000 mi | Ticking fuel injectors, all like that. Not fixed. | ||
| Aug 201330000 mi | Left speakers occasionally did not work. | ||
2010 Ford F-150 4dr Crew Cab 5.5ft bed
248-horsepower 4.6L V8 4-speed automatic RWD
| Ford F-150 in Texas, United States Sep 2010 - Jun 2022 | |||
| Jul 2017127000 miUS $350 | AC not cooling, previously diagnosed by dealer as a hose leak. Worked better but there's still an issue. | ||
| Jun 2021157000 miUS $3500 | replace ALL coils and plugs about $2,000 total replace cracked manifold..... repair cost about $1000 earlier replacement of break pads had to be redone because front pads had been installed incorrectly. warped rotors. total PITA. cost about $300. Problem caused by a DIFFERENT repair shop earlier in the summer of 2021 | ||
2010 Ford F-150 2dr Regular Cab 8ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in British Columbia, Canada Oct 2014 - Dec 2016 | |||
| Dec 201455180 miC $50 | cataletic oxygen sensor. Dealer did not have in stock and ordered it and then replaced it the next day. Excellent service | ||
| Ford F-150 in Michigan, United States Apr 2011 - Jun 2018 | |||
| Nov 201124000 miUS $30 | The traction control system would indicate failure erratically. Sometimes weeks apart. No codes were in the computer when they checked at the dealer. | ||
| Feb 201227000 mi | Clip that retained the drivers side sun visor was not holding properly. It was replaced. | ||
| Sep 201235000 mi | Traction control failure light comes on intermittently. It has since vehicle was new. The transmission temperature indicator started to indicate erratically. It used to reach normal temperature in 4-5 miles of driving or less. At times now it takes 15 miles. One day both the fuel gauge and the trip computer's distance to empty were reading erratically. But no codes and dealer could find nothing wrong. Hasn't happened again since. | ||
| May 201346000 miUS $26 | After backing down a long driveway (1/8 mile) the Check Engine light came on. The dealer found a code that said "turbine shaft speed discrepancy" caused the light. I had them cancel the code and it has not happened again. | ||
| Jul 201348000 mi | FORD emblem on the front grill was corroding and peeling. | ||
| Feb 201562000 miUS $250 | Noticed rust below the doors and behind the cab. It was fairly heavy rust and not light surface rust. Had body shop clean off the rust and spray Line-ex over the area. | ||
| Oct 201568500 miUS $500 | Premature rust in painted areas. Tailgate and wheel wells. | ||
2010 Ford F-150 2dr Regular Cab 8ft bed
292-horsepower 4.6L V8 6-speed automatic RWD
| Ford F-150 in Ontario, Canada Mar 2014 - Jun 2018 | |||
| Nov 2017161820 miC $1780 | exhaust manifold bolts - only 2 on left side and 3 on right side were not broken. The rest were broken and had to be drilled. 4X2 truck - remove bolts on rear trans mount , remove front engine mount bolts, rotate engine to get at manifold bolts. | ||
| Feb 2018172980 miC $574 | after driving 100km, stopped, put in reverse, stalled in 2 seconds. Started in park ok, stalled when put into D or R. Started and ran ok, Oil alarm said 2% left... not true, only 4,00km on oil. Towed to dealer, they had it 2 days - changed oil, -COULD NOT FIND ANY PROBLEM. - $575 for oil change and diagnosed 2 problems that they caused while working on the truck! Truck ran for 2 weeks.. now same problem and maybe torque converter gone...off to tranny shop now! | ||
| Ford F-150 in Alberta, Canada Nov 2010 - Jun 2022 | |||
| Sep 20116820 miC $175 | Remote start disabled by cab light switch | ||
| Mar 20129300 mi | shudder on 321 downshifts | ||
| Sep 201212400 mi | shudder on 321 downshift. TSB called for overhaul of Main control valve. | ||
| Mar 201526040 miC $100 | Tailgate lock seized | ||
| May 201632740 miC $300 | Driveshaft slip joint service | ||
2010 Ford F-150 2dr Regular Cab 8ft bed
248-horsepower 4.6L V8 4-speed automatic RWD
| Ford F-150 in Ohio, United States Aug 2010 - Mar 2013 | |||
| Oct 201238000 mi | 3rd brake light leaked | ||
| Ford F-150 in Virginia, United States Jun 2014 - Jun 2018 | |||
| Mar 2015112000 miUS $165 | Ignition coil replaced | ||
| Jan 2016124200 miUS $1500 | New ignition coils Front caliper stuck, new rotors and pads for front | ||
| Mar 2017135000 miUS $795 | Replaced intake head gasket. Leaking coolant and oil. | ||
| Ford F-150 in Ontario, Canada Oct 2010 - Jul 2016 | |||
| Aug 201223560 mi | Technician discovered leaking left-rear shock absorber during an oil change. Shock absorber replaced under warranty. | ||
| Aug 201552560 mi | Heat-shield loose, causing a rattling noise. Mechanic replaced fasteners. | ||
2009 Ford F-150
Engine not specified
| Ford F-150 in Texas, United States Apr 2009 - Mar 2010 | |||
| May 20092000 mi | Headliner falling down. Passenger seat trim coming off. | ||
| Ford F-150 in Ontario, Canada Dec 2012 - Dec 2013 | |||
| Oct 201365300 miC $165 | Clutch pack replacement. | ||
| Dec 201366340 miC $388 | Transmission rebuild. Full rebuild. Includes fresh u joint. | ||
| Ford F-150 in Saskatchewan, Canada Mar 2009 - Jun 2011 | |||
| Oct 20096200 mi | I started complaining about the way the truck shifted after the first week. The truck was repaired finally in October at my 10,000km maintenance and is fine now. I also had the Bluetooth speaker replaced, for the phone. Callers couldn't hear me when I was using the phone. My windshield was also replaced at that time, as it was broken during the speaker replacement somehow. | ||
| Ford F-150 in North Carolina, United States Oct 2014 - Jun 2015 | |||
| Nov 2014139200 miUS $1400 | Replaced compressor,condensor and orifice/expansion valve. Transmission bulk head connector started leaking two weeks after transmission fluid change. | ||
| Mar 2015140000 miUS $1400 | original plugs needed to be replaced and several coil packs were either weak or inop. Replaced all 8. | ||
2009 Ford F-150 4dr Extended Cab 8ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in British Columbia, Canada Aug 2013 - Apr 2018 | |||
| Aug 201324180 mi | Controls on driver side door cover came apart and new part was ordered and put in. | ||
| Jul 201631620 mi | New battery | ||
2009 Ford F-150 4dr Extended Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in Texas, United States Feb 2014 - Mar 2017 | |||
| Mar 201492000 mi | Control module for AC and and actuator motor. | ||
| Jun 2016115000 miUS $110 | O2 Sensor replaced. The rear sensor on drivers side. | ||
| Dec 2016121000 mi | All 4 tire sensor replaced in late 2016 | ||
2009 Ford F-150 4dr Extended Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Colorado, United States May 2009 - Jun 2011 | |||
| Jun 200911000 mi | hard shift from 1st gear to 2nd gear | ||
| Jul 201025200 mi | Battery loses charge after 3 days of no driving. They replaced the battery and it has not fixed the problem. Had to go back 5 days later for them to install the new radio and battery. | ||
| Apr 201133000 mi | Battery goes dead after 3 days of no use. I don't know what they did. They said it was fixed and to date it is still having the problem. | ||
| Ford F-150 in Ohio, United States Jun 2010 - Jun 2017 | |||
| Jan 201014000 mi | Technician check transmission for issues, none found. | ||
| Jul 201260000 mi | Truck started downshifting hard. Took to shop, they could not repeat the problem. | ||
| Aug 2016109000 miUS $1000 | Exahaust manifold gasket had to be replaced on the passenger side | ||
| Ford F-150 in Maine, United States Mar 2009 - Jan 2022 | |||
| Aug 200912000 miUS $65 | Flat tire. A prior flat repaired with a plug. Washboard road, gravel, plug blew out tearing tire. Tire was "replaced" with same size spare. "Take off" replaced spare... | ||
| Nov 201027000 mi | Sat antenna leaking, known issue in 2009 F150s Bad wheel bearing | ||
| Oct 201139000 miUS $190 | Pressure line was leaking on power steering. Flare appeared to be broken on inspection after replacement. | ||
| Nov 201139500 mi | Tailgate emblem fell off... | ||
| Jun 201463000 miUS $625 | Rear pinion seal, transmission pan gasket, front axle seals | ||
| Nov 201470300 miUS $50 | Shocks (rear) and struts (front) and front end alignment | ||
| Oct 201581300 miUS $525 | Block heater corroded, leaked antifreeze. Truck towed in. | ||
| Feb 201683000 miUS $2938 | Lost gasket @ left timing chain cover. Timing solenoid lost oil pressure, exploded chain tensioner. New everything between cams and crankshaft. | ||
| Apr 2017100000 miUS $175 | Tire pressure monitor sensor was bad. Changed when rotating snow tires on for winter. | ||
| May 2021139000 miUS $100 | Old caliper seized and needed replacement | ||
| Ford F-150 in Saskatchewan, Canada Oct 2013 - Sep 2015 | |||
| Jan 201549140 miC $620 | Bulkhead pass through leaking transmission fluid | ||
| Ford F-150 in New York, United States Mar 2012 - Jun 2022 | |||
| May 201226200 mi | Noticed water in rear roof liner and seat. dealer repaired leak near rear outside roof light. Dealer also replaced power mirror switch. | ||
| May 201344900 mi | connecting rod to latch that opens the rear door came off. opened inside door trim and reconnected | ||
| Dec 201471000 miUS $175 | water leaking from sat. roof radio antenna. dealer ordered special sealant. Oil leaking from transmission by the solenoid connection | ||
| Nov 201581700 miUS $85 | Rear differential seal replaced near the driveshaft | ||
| Dec 2016100000 miUS $200 | Both oxygen sensors in the exhaust system replaced | ||
| Feb 2017101000 miUS $75 | EVAP PURGE PUMP REPLACED. CLEARED SES LIGHT | ||
| Ford F-150 in Florida, United States Mar 2009 - May 2011 | |||
| Nov 201026200 mi | Leaking front shock | ||
2009 Ford F-150 4dr Extended Cab 6.5ft bed
292-horsepower 4.6L V8 6-speed automatic RWD
| Ford F-150 in Florida, United States Apr 2015 - Jan 2022 | |||
| Aug 201562600 miUS $20 | Water pouring into cab through third brake light. Very common problem on that entire series of truck yet Ford has done nothing | ||
| Jan 201882000 miUS $1200 | Quit blowing as cold but does eventually cool the can down, the heat quit working as well | ||
| Ford F-150 in Washington, United States Aug 2009 - Aug 2019 | |||
| Jun 201123000 mi | Driveline "clunk" on stopping. Shop removed boot on slipjoint, installed different lube, replaced boot. Problem solved. When towing, downshift from 5th to fourth exceptionally hard and jarring. Shop could no replicate. Only apparent when towing 5K Lb. load. | ||
| Jul 201460300 mi | Hard downshifts into first, and from 5 to 4. Dealer reflashed the controller, which took several tries. Excellent result! | ||
| Aug 201460000 mi | Excessively hard downshifting from 5 to 4, and 2 to 1. Dealer reflashed controller, had to go through the process several times to get it to "take". Problem is now resolved. | ||
| Jul 2018104000 miUS $32 | Check engine code, rough running. I replaced a single fuel injector. Cost $32 +/-, my labor was free. | ||
2009 Ford F-150 4dr Extended Cab 6.5ft bed
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Indiana, United States Sep 2009 - Dec 2011 | |||
| May 201013000 mi | Had one defective tire pressure monitoring sensor | ||
| Ford F-150 in North Carolina, United States Mar 2009 - Feb 2017 | |||
| Jun 201038000 mi | Tire Pressure Sensor Failure. Dealer had trouble identifying the failed sensor. Took a total of three trips plus several caal. | ||
| Ford F-150 in North Carolina, United States Aug 2009 - Aug 2010 | |||
| Jun 201020000 mi | Transmission shuddered on gear change, firmware updated, persistent "learning" memory cleared. Problem reduced but not eliminated. Pursuing further repair options. | ||
| Ford F-150 in Manitoba, Canada Feb 2010 - Dec 2011 | |||
| Oct 201017360 mi | power steering hose leak. fixed under warranty. | ||
2009 Ford F-150 4dr Extended Cab 6.5ft bed
248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range
| Ford F-150 in Ohio, United States Jan 2011 - Mar 2011 | |||
| Mar 201111000 mi | traction control light was on. Fairway ford in canfield ohio replaced passenger rear speed sensor under warranty in less than an hour after my arrival washed truck and notice water dripping into cab over rear seats. Dealer ordered the part and i had to return a week later, dealer replaced 3rd brake light for leaking | ||
2009 Ford F-150 4dr Extended Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in California, United States Mar 2010 - Nov 2018 | |||
| Aug 201214600 mi | Sun roof track | ||
| Ford F-150 in Ontario, Canada Jun 2021 - Jun 2022 | |||
| Sep 2021102300 miC $3500 | Nearly full A/C replacement | ||
| Ford F-150 in Ohio, United States Nov 2012 - Jul 2015 | |||
| Jan 201390000 miUS $106 | low RPM sensor - ford dropped engine | ||
| Sep 2014125000 miUS $450 | Module that controls vent bi-pass and closure quit working for passenger side vents. When A/C was cooling my side it was heating passenger side. I have had several ventilation malfunctioning issues with this truck. | ||
| Ford F-150 in Illinois, United States Mar 2011 - Jun 2018 | |||
| Jun 201314000 miUS $99 | Engine unintentionally accelerated. | ||
2009 Ford F-150 4dr Extended Cab 5.5ft bed
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Michigan, United States Aug 2013 - Sep 2013 | |||
| Sep 201348000 mi | Cam tensioner blew a gasket, replaced both, replaced cam solenoid. then replaced cam phasers. | ||
| Ford F-150 in Iowa, United States Mar 2009 - Jul 2016 | |||
| Dec 200911000 mi | A rear sensor connected to braking system failed, causing warning light. Sensor replaced. | ||
| Mar 201571000 miUS $100 | fluid leak, future repairs will be needed, part ordered | ||
| Mar 201684000 miUS $450 | Malfunctioning sensor related to engine status Nonfunctioning bulbs within turn signal system | ||
2009 Ford F-150 4dr Crew Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in Wisconsin, United States Oct 2011 - Sep 2013 | |||
| Jul 201246300 mi | replace tie rod end | ||
| Feb 201356300 mi | Intermitant rough idle,, Cam sensor came up on scan. Replaced cam sensor under warranty | ||
| Ford F-150 in Tennessee, United States Mar 2012 - Oct 2015 | |||
| Oct 201555000 mi | power steering lines and pump need replaced. have not fixed it yet. haven't been driving it. | ||
2009 Ford F-150 4dr Crew Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in British Columbia, Canada Feb 2010 - Jun 2011 | |||
| Apr 20107440 mi | satellite antenna (leaking into cab) third brake light (leaking into cab) instrument cluster (transmission temperature gauge malfunction) satellite antenna (leaking into cab) third brake light (leaking into cab) instrument cluster (transmission temperature gauge malfunction) | ||
| Ford F-150 in Texas, United States Sep 2009 - Aug 2013 | |||
| Nov 20093000 mi | Seat trim was coming loose from the frame, repaired under a TSB Drivers seat backrest motor was making noise when being adjusted. Dealer replaced seat motor. | ||
| Jan 201114200 mi | Driver door not unlocking properly all the time, problem was found to be the door latch assembly. Dealer replaced latch assembly Experiencing an occasional harsh shift from 1-2 when cold. Dealer performed a TSB to reflash the transmission control unit. Problem | ||
| Nov 201113200 mi | Driver interior door handle broke. Took to shop and was advised that the door handle was a part of a recall. All 4 handles were replaced. | ||
| Apr 201214200 mi | Water was leaking in through the third brake light. The dealer diagnosed as part of a service bulliten and replaced the seal around the lamp. This also required the replacement of the headliner and cleaning of the interior for water stains. | ||
| Ford F-150 in Arkansas, United States Jun 2009 - Jun 2017 | |||
| Nov 20095000 mi | Bad paint in bed of truck. Made appt. week in advance. got there, no record of made appt. left truck for 10days. | ||
| Jun 201014000 mi | drivers door handle broke | ||
| Jun 201127000 mi | water coming into cab back seats from third brake light. replaced seal | ||
| Ford F-150 in California, United States Mar 2009 - Jun 2015 | |||
| Dec 200921000 mi | Install new sun glass holder, the old one broke, the new one came in the wrong color had to wait another 2 weeks till completion | ||
| Apr 201029000 mi | Valve Cover had a leak | ||
| Jan 201263000 miUS $87 | Blower Resistor went out, heat would only operate on full. Plastic piece near the side step missing | ||
| Jun 201599000 mi | Sometimes the window wouldn't go up. | ||
| Ford F-150 in Alberta, Canada Jan 2013 - Jul 2017 | |||
| Apr 201376880 miC $400 | power steering pressure hose leak. | ||
| Dec 2015110360 miC $8 | Weeping pinion seal replaced. | ||
| Ford F-150 in Alberta, Canada Oct 2014 - Jul 2019 | |||
| Jan 201545260 mi | Transmission gasket developed a leak and had to be replaced. | ||
| Jun 201547120 miC $700 | Fault in the Airbag system was traced to a faulty seatbelt actuator. Actuator was replaced | ||
| Dec 201549600 miC $1 | Transmission Connector leaking transmission fluid | ||
| Jun 201755180 mi | Leak on intake manifold | ||
| Apr 201959830 miC $1700 | Replaced CAM Phasors | ||
| Ford F-150 in New York, United States Aug 2009 - Jan 2013 | |||
| Dec 201133000 miUS $200 | Tire pressure sensor failure. | ||
| Ford F-150 in Texas, United States Feb 2013 - Jan 2016 | |||
| Dec 201584000 mi | driver seat motorized lumbar broken | ||
2009 Ford F-150 4dr Crew Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic RWD
| Ford F-150 in Mississippi, United States Nov 2012 - Apr 2014 | |||
| May 201361000 miUS $100 | Power Steering pressure hose had a small leak and was replaced. | ||
| Jan 2014US $100 | Engine noise. Camshaft phasers were replaced | ||
| Apr 201472500 mi | Dealer was supposed to replace the VCT Solenoids but they didn't. Dealer kept vehicle 4 days to replace the SVT Solenoids but never replaced them. I told them to put the valve cover back on and left and traded the vehicle in. | ||
| Ford F-150 in Louisiana, United States Oct 2009 - Jun 2018 | |||
| Nov 201581400 miUS $50 | AC blend door actuator needed to be replaced | ||
| Mar 201799000 miUS $200 | TPMS sensors failed. 2 replaced. Also the one of the surface mount LEDs went out on the tachometer in the instrument cluster, leaving a dim spot at night. | ||
| Dec 2017106000 miUS $50 | 2nd blend door actuator failure and replace | ||
| Feb 2018111000 miUS $200 | leaking Oring around transmission bulkhead connector. This is has TSB from ford they installed the wrong material of orings from the factory. | ||
| Ford F-150 in Texas, United States Dec 2011 - Apr 2013 | |||
| Aug 201223100 mi | power steering line leaking. | ||
| Ford F-150 in Texas, United States Jul 2009 - Jun 2011 | |||
| Nov 200917000 mi | Reported a positioning problem with the rear seat/shoulder belts to FMC. Said they could do nothing until I took it into the dealer. Problem is that the rear shoulder belts cut into my 5' tall wife's neck and my 5'2 mothers neck. Sent pictures, nada. | ||
| Ford F-150 in Mississippi, United States Dec 2013 - Jun 2018 | |||
| Mar 201461000 miUS $7300 | Dealer replaced the engine. Not under warranty. Claimed something failed internally to engine. Replaced Engine | ||
| Jan 201581000 miUS $800 | Replaced head and camshaft. Ford told me that the bolts holding the camshaft in place were not properly tightened on the new engine that was put in the truck. The bolts were loose when they removed the camshaft and head. The PCM (computer) had to be replaced first at a cost of $8xx.xx because Fords troubleshooting pointed to the PCM being replaced before they could go any further with identifying why the check engine light was on. Replaced head and camshaft. | ||
| Sep 201576000 miUS $100 | Check Engine Light. OBD indicated drivers side oxygen sensor before catalytic converter was bad | ||
| Feb 2017100000 miUS $285 | Took alternator into shop for replacement but alternator was not bad. | ||
| Mar 2017105000 mi | Getting notification to "Check Charging System". | ||
| May 2018113000 mi | Check Charging System light came on. Evidently, not driving the truck for extended periods caused the problem. Once I started driving it, the problem went away. | ||
2009 Ford F-150 4dr Crew Cab 5.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Minnesota, United States Aug 2009 - Jun 2015 | |||
| May 20094295 mi | Paint problem, two different colors on the front and rear halves of the vehicle. Repainted vehicle | ||
| Jul 20096500 mi | Fabric failure on passenger headrest, both front seat covers detached from seat frame. | ||
| Sep 200911000 mi | Since new, front seat covers would detach from seat frame. Been in 3 times. Covers replaced this trip | ||
| Oct 200910000 mi | Headrest fabric failure. Front seat covers detached from frame. Covers replaced this visit. | ||
| Feb 201022000 mi | Tail light bulb replaced | ||
| Mar 201145000 miUS $54 | Annoying harmonic sound caused by worn/defective exhaust pipe hanger. Hanger replaced | ||
| Oct 201284000 miUS $340 | Tailgate torsion bar and bushings wore out. | ||
| Mar 201392000 miUS $50 | Vehicle lost significant amount of ATF. Unable to find leak | ||
| Dec 2014138000 miUS $1272 | Rough run, low power. Replaced both variable timing actuators (variable valve timing system) | ||
| Ford F-150 in Delaware, United States Sep 2013 - Jul 2015 | |||
| May 201548900 miUS $350 | Back sliding window and over rear light in cab had water leakage. Said it was a bad seal around third break light | ||
| Ford F-150 in Manitoba, Canada Jul 2009 - Dec 2013 | |||
| Dec 201349600 miC $990 | Complained of tire or bearing noise but dealer advised it was tires and was caused by loose Upper control arms. Mostly highway driven so not expecting this type of problem so early. | ||
| Ford F-150 in Tennessee, United States Jan 2014 - Sep 2015 | |||
| Feb 201599000 miUS $410 | MPG dropped from 16-18 to 9-11. Engine light on. Had to have the O2 sensor (Bank 1 sensor 1)replaced. Had the O2 sensor (Bank 2 sensor 1)replaced. | ||
| Ford F-150 in Saskatchewan, Canada Jul 2009 - Jun 2011 | |||
| Feb 201017980 mi | Sync system stopped responding. No voice command, no bluetooth, no USB or Line in connection. Satellite, radio and CD continued to function. | ||
| Ford F-150 in Ontario, Canada Mar 2011 - Jun 2017 | |||
| Sep 201163860 mi | short in fan blower motor made it so fan was either off or on full blast. | ||
| Apr 201279300 miC $50 | automatic deploying running board motor failure | ||
| Feb 2013110280 mi | Oil leak, seal replaced motor failure on deployable running board, drivers side | ||
| Nov 2013134500 miC $212 | blower motor controller failed and needed to be replaced. | ||
| Nov 2015187860 miC $400 | front caliper curb side was sticking. Had both front calipers replaced and brakes relined. | ||
| Jan 2016146700 miC $75 | fuse melted that controls injectors, there is a service bulletin on this issue. | ||
| Ford F-150 in Colorado, United States May 2009 - Nov 2013 | |||
| Aug 20096000 mi | Hard upshifting Transmission gears 1-2 and downshifting 2-1 | ||
| Ford F-150 in Maryland, United States Jan 2017 - Jul 2018 | |||
| Jul 201857000 miUS $100 | replaced rotors and brake pads. | ||
| Ford F-150 in Washington, United States May 2009 - Jun 2011 | |||
| Mar 201012000 mi | Third brake light leaking water | ||
| Ford F-150 in Texas, United States Apr 2009 - Mar 2011 | |||
| Jun 20091000 mi | Passenger bottom seat cushion leather came undone in front where it attaches to the seat frame. Dealer repaired while installing an anti theft alarm, but it came undone shortly after the repair. Probaly fix it myself; Dealer experiences always bad! | ||
| Ford F-150 in Texas, United States Aug 2009 - Dec 2012 | |||
| Sep 20094000 mi | Trim was damaged at delivery and Paint had to be repaired after Dealer scratched it during a previous repair | ||
| Ford F-150 in California, United States Feb 2013 - Mar 2017 | |||
| Apr 201398000 miUS $50 | Check Engine came on, it was a problem with the transmission computer. Ford flashed a new OS to the transmission computer and I was done. | ||
| Aug 2013103600 miUS $1200 | Four of eight ignition coils failed, taking the corresponding spark plugs with them. | ||
| Ford F-150 in Florida, United States Sep 2009 - Oct 2022 | |||
| Feb 20108000 mi | Transmission reprogramming due to harsh shifting, battery replaced, wife killed the battery enough times to ruin it (no fault of ford) | ||
| Feb 201576000 miUS $50 | Heater blend door motor failed on the passenger side. This caused the dual zone AC/heat to fail in the "heat" position. Since I'm in South Florida, this is not good. | ||
| Apr 2017104000 miUS $40 | Passenger blend door actuator failed again. Blend door is free and moves easily. These actuators are not easy to change, and fail with regularity. | ||
| Mar 2018117000 miUS $450 | AC compressor disintegrated, completely filling the low pressure side of the system with debris, including the evaporator. The repair included replacing the compressor, removal and cleaning of the lines and evaporator. Replacement of the expansion valve. Significant leak at transmission electrical connector o-rings (a known problem) . Requires pan removal, release of the connector, installation of new o-rings and new transmission fluid. | ||
| Jan 2022165000 miUS $100 | Shift cable broke, truck stuck in park | ||
| Ford F-150 in Alberta, Canada Nov 2009 - Jun 2018 | |||
| Jan 20119300 mi | Drivers heated seat stopped working. Replaced heating element. | ||
| Oct 201440280 miC $1200 | Replace blend door actuator on driver side for heater | ||
| Mar 201657040 miC $380 | Transmission bulkhead seal leaking | ||
| Jun 201879980 mi | Rear pinion seal leak. | ||
| Ford F-150 in Manitoba, Canada Nov 2009 - Dec 2017 | |||
| Sep 201328520 miC $500 | Seeping power steering hose | ||
| Nov 201550300 miC $125 | TPS on RR tire replaced | ||
| Dec 201769440 miC $200 | Replaced battery after failure. | ||
| Ford F-150 in Kansas, United States Mar 2010 - Aug 2019 | |||
| Aug 201692100 miUS $50 | Check engine light | ||
| Dec 2017109000 miUS $100 | Replace battery | ||
| Ford F-150 in Texas, United States Jan 2012 - Jun 2022 | |||
| Oct 2021193000 miUS $250 | Alternator started making a loud whining noise and was not charging efficiently. | ||
| Ford F-150 in Georgia, United States Feb 2010 - Jan 2011 | |||
| Jun 201025000 mi | inside door handle broke | ||
| Ford F-150 in Ontario, Canada Oct 2009 - Apr 2013 | |||
| Sep 201023560 mi | hard shifting on downshift and high rev at acceleration TB - reset transmission memory | ||
| Nov 201139140 mi | Harsh down shifting 3rd to 2nd, flashed computer - ok now | ||
| Ford F-150 in Florida, United States Mar 2015 - Sep 2017 | |||
| Jan 2017US $140 | battery dead | ||
| Ford F-150 in Louisiana, United States Aug 2011 - Oct 2015 | |||
| Oct 201134523 mi | the sun visor clip was not tight causing a rattle. covered under warranty. the sun visor clip was not tight causing a rattle. covered under warranty. | ||
| May 201480100 miUS $100 | ac gate | ||
| Mar 201586000 miUS $100 | Leaking power steering hose | ||
| Aug 201593800 miUS $100 | Check engine light on, Code p0345. New sensor ordered. Not received or installed yet. | ||
| Oct 201598000 miUS $100 | cam sensor | ||
| Ford F-150 in New York, United States Dec 2011 - Mar 2014 | |||
| Dec 201340000 miUS $420 | Power steering hose leak transfer case leak | ||
| Ford F-150 in Texas, United States Feb 2014 - Jul 2014 | |||
| Mar 201491000 miUS $120 | Sunroof track broke and would not close. Would have been a very costly repair if the dealership did not cover the cost. Bad problem. Would advise having sunroof checked for problems as often as possible. Third brake light was leaking water into cabin on the back wall of the truck. Stained top of seats. Ford knew exactly what the problem was before I said more than 2 sentences. Needed new type of 3rd brake light assembly. 110$ plus gas. | ||
| Ford F-150 in Michigan, United States Aug 2009 - Mar 2015 | |||
| Mar 201565000 miUS $4000 | Triple white paint seems to have trouble rusting. Back bumper and doors. Platinum has mechanical side steps. They stay in the down state even when driving. In the cold they will not return to up position. In the snow its impossible even with mechnical assistance. | ||
| Ford F-150 in California, United States Mar 2010 - Aug 2014 | |||
| Jun 201018500 mi | The truck was incorrectly wired from the factory which caused the truck to die and not restart. Ford paided for the labor, parts, and tow. | ||
2009 Ford F-150 4dr Crew Cab 5.5ft bed
292-horsepower 4.6L V8 6-speed automatic RWD
| Ford F-150 in Illinois, United States Feb 2011 - Mar 2016 | |||
| Dec 201245000 miUS $21 | 6 bolt Front sealed bearing hub RWD Not trailer towing. $100 dollars cheaper at Rock auto than local parts supply. Developed slowly. Blower not working on 2 lower speeds. Replaced resistor card behind right kick panel. | ||
| Jan 201670000 mi | Heat shield on right exhaust manifold was found rusty out and lying on frame. Dealer wanted $88 to replace. Should not have happened at such low millage. I think should be recalled and replacement made of stainless steel, | ||
| Ford F-150 in California, United States Oct 2010 - Jun 2012 | |||
| Jan 2011 | Right cylinder bank cam phaser. There was a deep ticking/knocking at low engine speeds when up to operating temp., made it sound like a sewing machine driving around parking lots! | ||
| Ford F-150 in California, United States Jul 2009 - Mar 2013 | |||
| Oct 201139000 miUS $123 | roof water leak. repaired with replacement of third brake light lens. | ||
| Ford F-150 in North Carolina, United States Dec 2009 - Jun 2011 | |||
| Oct 20091700 mi | Hard down shifting. Thunking sound from drivetrain. Dealer did TSB for downshifting problem and stated this should fix thunking sound. Thunking & hard down shifting still exists. | ||
| Nov 20092200 mi | TCS light constantly on. Dealer diagnosed and replaced TCS module. | ||
| Jan 20106200 mi | Thunking sound when shifting. Dealer removed drive shaft, cleaned out old grease and replaced with a teflon based grease per Ford. Issue resolved! When accelerating after stop and then making a turn trucks RPM would go to approx. 5k rpm and then suddenly drop to around 2k rpm and would still be in 1st gear. Almost had a rear end accident due to the rapid drop and loss of speed. | ||
| Jul 201019000 mi | Transmission shifting issues and slipping both reverse and trying to pass. Complained since the first 1,000 miles on truck and finally Field Service Engineer confirmed my issue. Transmission replaced not repaired as damage was extensive. | ||
| Ford F-150 in Texas, United States Dec 2011 - Feb 2015 | |||
| Jan 2012 | The power steering was leaking and they had to order the part. Called me two months later telling me it was in. Drove in to have it installed and it was the wrong part. It has been 3 more weeks and still waiting on part. | ||
| Feb 201233000 mi | The truck has died on me 3 times causing me to place the truck into park, start the engine, and place the transmission back into drive. Two times it died from taking off and the third time I was turning off of a busy road. There was a bump in the transmission when taking off. It ended up being the slip yolk not properly being lubricated from the manufacturer. | ||
2009 Ford F-150 4dr Crew Cab 5.5ft bed
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Texas, United States Jun 2009 - Mar 2014 | |||
| Sep 201022000 mi | cab third brake light lens leaked, filled back seat with rain.Cleaned headliner and seat. | ||
| Jan 201128000 mi | steering wheel started peeling | ||
| May 201135000 mi | Chrome was peeling off grille, it was replaced. | ||
| Apr 201366700 mi | cab brake lite leaked again. | ||
| Ford F-150 in North Carolina, United States Dec 2011 - Dec 2015 | |||
| Dec 201338000 miUS $10 | Common, well-documented issue with water leak at third brake light. Ford will only replace entire unit at $100+ and same gasket. I fixed by removing light, adding silicone and reinstalling. | ||
| Feb 201440000 miUS $390 | Another common issue with 2009 F150s. Lower power steering high pressure fluid hose leaking. Part retailed ~$140, labor and fluid was extra. I was out of warranty when it happened | ||
| Jan 201540800 mi | Third brake light leaked again. Common issue with these trucks. I re-caulked it. | ||
| Ford F-150 in Manitoba, Canada Dec 2014 - Apr 2015 | |||
| Jan 2015131300 miC $380 | Replaced high and low pressure power steering hoses and transmission cooler lines. All weeping for past two years, now some leaking. | ||
| Mar 2015137020 miC $210 | Power steering hose rupture. | ||
2009 Ford F-150 2dr Regular Cab 8ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Kansas, United States Jun 2011 - Dec 2012 | |||
| Apr 201125000 miUS $26 | turned rotor that was warped | ||
| Jun 201128000 miUS $26 | replaced defective ash tray door replaced power steering hose that was seeping | ||
2009 Ford F-150 2dr Regular Cab 8ft bed
248-horsepower 4.6L V8 4-speed automatic RWD
| Ford F-150 in California, United States Apr 2012 - Mar 2013 | |||
| Jun 201222000 mi | yet another warranty repair to the steering. | ||
| Oct 201225700 miUS $698 | Was reported to me that Struts were leaking, I paid for repair and asked for parts. Struts turned out to not be leaking but they went ahead and replaced them anyway. | ||
2009 Ford F-150 2dr Regular Cab 6.5ft bed
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Minnesota, United States Apr 2015 - Dec 2017 | |||
| May 201592000 miUS $2000 | vct actuators | ||
2009 Ford F-150 2dr Regular Cab 6.5ft bed
248-horsepower 4.6L V8 4-speed automatic RWD
| Ford F-150 in Massachusetts, United States Jul 2010 - Aug 2015 | |||
| Sep 201016000 miUS $464 | Factory tow harness not completely installed. Trailer service shop installed new harness without my permission and charged an arm and a leg. Even though I bought the truck used Ford later came through and reimbursed me. | ||
2009 Ford F-150 2dr Regular Cab 6.5ft bed
248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range
| Ford F-150 in Texas, United States Jan 2010 - Jun 2018 | |||
| Aug 201110600 mi | Rear shock replaced, leaking | ||
| Sep 201420000 miUS $122 | Shocks were leaking. Replaced both. | ||
See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.
