TSB Date | Problem Area | TSB Text |
06/03/08 | NHTSA ID: 10024865 TSB ID: 20228 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj |
|
02/20/08 | NHTSA ID: 10023943 TSB ID: 07212 Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. |
|
07/23/07 | NHTSA ID: 10022243 TSB ID: 19728 Lack of power due to low fuel pressure - fuel tank liner seperation. |
|
06/12/07 | NHTSA ID: 10021621 TSB ID: 19621 Lack of power due to low fuel pressure, fuel tank liner seperation. |
|
03/28/07 | NHTSA ID: 10021281 TSB ID: 07312 Water in the fuel tank behind rear axle - 6.0l, 6.4l and 7.3l diesel engine. updated 2/29/08. *nj |
|
02/10/06 | NHTSA ID: 10019075 TSB ID: 19015 Fuel conditioner. low power, poor fuel economy, fuel gelling in cold weather, excessive white smoke on cold start, hard start, or coking of components exposed to exhaust. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
01/12/06 | NHTSA ID: 10018745 TSB ID: 041601 Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. |
|
05/05/05 | NHTSA ID: 10014666 TSB ID: 05417 Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. |
|
05/05/05 | NHTSA ID: 10014685 TSB ID: 0554 Use of stainless steel exhaust studs in service for 5.4l 2v engine. |
|
04/18/05 | NHTSA ID: 10013413 TSB ID: 04236 Vehicle lean sag when observed from rear of vehicle. *eh |
|
01/06/05 | NHTSA ID: 10011162 TSB ID: 031404 Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04. |
|
12/07/04 | NHTSA ID: 10010731 TSB ID: 18217 Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. |
|
| ||
12/07/04 | NHTSA ID: 10010734 TSB ID: 18223 Vacuum pump inoperative or runs continuously - climate control defaults to defrost. oasis. to also include 2005 super duty f-series, excursion, and f650/750. |
|
08/09/04 | NHTSA ID: 10008589 TSB ID: 02194 Driveability-no start/repeat starter failure-repeat starter replacement. electrical-sticking or binding ignition lock cylinder between start and run. engine-starting-starter staying engaged at start up. *mj |
|
08/05/04 | NHTSA ID: 10008580 TSB ID: 02176 Lamp-brake-invadvertent disabling of brake shift interlock. *mj |
|
08/04/04 | NHTSA ID: 10008552 TSB ID: 17777 Rear leaf spring noise. |
|
07/28/04 | NHTSA ID: 10008334 TSB ID: 16403 Engine-light tick or rattle type noise from engine after cold start. *mj |
|
07/27/04 | NHTSA ID: 10008310 TSB ID: 02227 Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj |
|
Looking for a warranty? Get a quote.
|
||
07/26/04 | NHTSA ID: 10008288 TSB ID: 17406 Low power, poor fuel economy, fuel gelling cold, excessive white smoke cold, or hard start. *mj this oasis updates previous oasis dated 12/01/03. |
|
07/22/04 | NHTSA ID: 10008166 TSB ID: 17316 Fuel signal to instrument cluster service tip. |
|
07/22/04 | NHTSA ID: 10008169 TSB ID: 17320 Broken exhaust manifold studs. |
|
07/22/04 | NHTSA ID: 10008119 TSB ID: 17554 Oil/dust film at cac connections. *mj |
|
01/14/04 | NHTSA ID: 10004888 TSB ID: 03205 No start/repeat starter failure or a sticking/binding ignition lock cylinder, starter staying engaged at start up. also includes 2003 super duty f series. |
|
01/13/04 | NHTSA ID: 10004881 TSB ID: 16518 Accessory drive belt squealing noise from the engine area when the engine fan clutch is engaged while operated in hot dusty climates. various models including 2003 f450/550. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
01/13/04 | NHTSA ID: 10004882 TSB ID: 16589 Gradual loss of power at cruise. ford special service message. various models including 2003 super duty f series. |
|
01/13/04 | NHTSA ID: 10004883 TSB ID: 16859 Some vehicles built after 12/7/1998 equipped with a 7.3l dit engine may exhibit a hoot or howling noise from the turbocharger. 2003 super duty f series also included. |
|
01/12/04 | NHTSA ID: 10004852 TSB ID: 032141 Fuel quality and moisture in certain diesel fuels may cause some vehicles to exhibit a no start, gradual loss of power, or a rough idle condition due to fuel gelling during extreme cold weather operation. |
|
01/12/04 | NHTSA ID: 10004853 TSB ID: 032142 A lack of power under a load, at cruise or on acceleration may occur on some vehicles built before 11/25/2000 equipped with the 7.3l dit engine. |
|
01/12/04 | NHTSA ID: 10004854 TSB ID: 032143 Some cuautitlan built vehicles equipped with the 7.3l powerstroke diesel engine with engine serial number between 5000000 and 5008850 may exhibit a low oil pressure condition. |
|
01/12/04 | NHTSA ID: 10004856 TSB ID: 032145 External oil leak diagnosis for 7.3l dit engines. various models including 2003 super duty f series. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
01/12/04 | NHTSA ID: 10004857 TSB ID: 032146 Engine oil pan corrosion on vehicles equipped with the 7.3l diesel engine. various models including 2003 super duty f series. |
|
01/12/04 | NHTSA ID: 10004860 TSB ID: 032149 A loss of power, oil leaks around the turbo, and/or excessive exhaust noise from the turbo. |
|
01/12/04 | NHTSA ID: 10004861 TSB ID: 032150 High pressure oil pump leak on vehicles equipped with 7.3l diesel engine. |
|
01/12/04 | NHTSA ID: 10004862 TSB ID: 032151 Some 7.3l diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (ebp). this article supersedes tsb 03-21-51 dated 10/30/2003. |
|
11/14/03 | NHTSA ID: 10004032 TSB ID: 03192 Leak oil around the exhaust backpressure actuator (ebp) - 7.3l diesel turbocharger pedestals. |
|
11/14/03 | NHTSA ID: 10004039 TSB ID: 031910 Brake pull. 4x4 f-250/350 and excursion vehicles only. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/14/03 | NHTSA ID: 10004025 TSB ID: 03174 Steering wheel fight after riding over bumps/ruts. 2003, 2004 f450 and f550 models included. |
|
10/29/03 | NHTSA ID: 10003743 TSB ID: 03143 Front hubs will not engage or disengage properly. |
|
10/29/03 | NHTSA ID: 10003744 TSB ID: 03144 Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. |
|
10/29/03 | NHTSA ID: 10003749 TSB ID: 03149 A loss of power, oil leaks around the turbo, and/or excessive exhaust noise from the turbo. |
|
10/29/03 | NHTSA ID: 10003750 TSB ID: 031410 Turbo pedestal seal oil leak around the exhaust back pressure (ebp) actuator. 2003 super duty f series included. |
|
09/17/03 | NHTSA ID: 10002783 TSB ID: 03911 Rough idle and/or hesitation when acclerating on certain super duty vehicles equipped with a 5.4l or 6.8l engine. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
09/17/03 | NHTSA ID: 10002780 TSB ID: 0398 Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. |
|
09/16/03 | NHTSA ID: 10002767 TSB ID: 03103 Vehicles without the coolant lock-off may exhibit a no start condition. |
|
09/16/03 | NHTSA ID: 10002773 TSB ID: 03112 On-vehicle front integrated hub/bearing rocking end-play measurement. including 2003 and 2004 super duty f series. |
|
09/09/03 | NHTSA ID: 10002632 TSB ID: 16921 Coolant leak due to broken radiator hose clamp. 1999-2003 models. |
|
09/09/03 | NHTSA ID: 10002635 TSB ID: 16924 Slight purge of grease from the hub bearing unit. this grease may be noted between the hub unit and the inboard rotor flange and on the inboard side of the bearing. 1999-2003 models. |
|
09/08/03 | NHTSA ID: 10002606 TSB ID: 16891 Clear gel-like substance in the hydraulic brake master cylinder reservoir. this substance is a silicone base lubricant used during assembly of the master cylinder. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
09/04/03 | NHTSA ID: 10002512 TSB ID: 16662 Lack of power, smoke, or oil leaks around the charge air cooler (cac). 1999-2003 super duty/excursion vehicles equipped with 7.3 or 6.0 ford navistar diesel engine. |
|
09/03/03 | NHTSA ID: 10002486 TSB ID: 16597 Coolant leak due to a broken lower radiator hose clamp. |
|
12/06/02 | NHTSA ID: 637789 TSB ID: 15902 Some vehicles may exhibit lack of power steering assist. |
|
12/06/02 | NHTSA ID: 637836 TSB ID: 15932 Some vehicles equipped with 4.2l, 4.6l and 5.4l engine may exhibit a lack of power condition. |
|
12/04/02 | NHTSA ID: 637696 TSB ID: 15851 Some 5.4l windsor power improved engines may exhibit a slight oil leak or weep at the cylinder head to block joint. |
|
12/04/02 | NHTSA ID: 637757 TSB ID: 15888 Some vehicles may exhibit a fead belt squeal. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
12/03/02 | NHTSA ID: 637569 TSB ID: 15827 Some vehicles equipped with lpg engine may exhibit the two fuel gauges displaying different fuel levels. |
|
11/07/02 | NHTSA ID: 636250 TSB ID: 16048 Some vehicles may exhibit cluster fuel tank gauge and lpg tank gauge display different readings. |
|
11/07/02 | NHTSA ID: 636306 TSB ID: 15678 Coolant leak due to a broken lower radiator hose clamp. |
|
11/07/02 | NHTSA ID: 636346 TSB ID: 15709 Some vehicles may exhibit a long fuel filling time when temperature within the tank is high, the overfill valve is closed and the service pump station has very low hp rate. |
|
11/07/02 | NHTSA ID: 636380 TSB ID: 15742 Information on vehicles exhibiting a perceived poor fuel range / economy, and or a faulty fuel gauge. |
|
11/05/02 | NHTSA ID: 636074 TSB ID: 02104 Some bi-fuel lpg vehicles may exhibit a no start, rolling idle, surging idle and / or surge at cruise condition in lpg mode with alt fuel green light on. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/05/02 | NHTSA ID: 636083 TSB ID: 02108 Some vehicles equipped with the 5.4l 2v engine may exhibit a whistling noise fromthe formed nylon tube inthe idle-air bypass flow circuit. |
|
06/25/02 | NHTSA ID: 631905 TSB ID: 01017 Subject regarding 198196 bolt-on steering stops service group, all models 0307, hr0307a and hr1000a. *slc |
|
04/23/02 | NHTSA ID: 630725 TSB ID: 15661 Concerns with rattle noises coming from front brake calipers. |
|
04/18/02 | NHTSA ID: 630515 TSB ID: 01246 Engine oil system priming procedures, service tips for reports of premature engine failure. |
|
04/18/02 | NHTSA ID: 630609 TSB ID: 15500 Concerns with low power while in reverse. |
|
04/17/02 | NHTSA ID: 630414 TSB ID: 15398 Some vehicles may exhibit a coolant leak due to a broken radiator hose clamp. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
04/16/02 | NHTSA ID: 630370 TSB ID: 15446 Some vehicles may exhibit increased steering efforts at very low speeds or when stopped with the brakes applied. |
|
04/15/02 | NHTSA ID: 630126 TSB ID: 15578 Some vehicles may exhibit an anti-lock brake system (abs) light on, b2141/b2477, and/or an inaccurate speedometer. |
|
04/15/02 | NHTSA ID: 630130 TSB ID: 15579 Some vehicles may exhibit caliper pin rattle noise originating from the front brake calipers. |
|
04/15/02 | NHTSA ID: 630239 TSB ID: 15328 Concerns with rattle noise originating from the front brake calipers. |
|
04/12/02 | NHTSA ID: 630053 TSB ID: 15525 Information regarding a rattle noise originating from the front brake caliper.*yd |
|
04/12/02 | NHTSA ID: 630064 TSB ID: 15533 Subject regardidng squeak and rattle condition. *yd |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
04/11/02 | NHTSA ID: 630001 TSB ID: 0214 Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. |
|
04/11/02 | NHTSA ID: 630013 TSB ID: 0218 Some bi-fuel vehicles may exhibit a no start in alt fuel mode. |
|
02/26/02 | NHTSA ID: 627927 TSB ID: 01205 Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. |
|
11/30/01 | NHTSA ID: 625713 TSB ID: 01173 Vibration - driveline drone or vibration - felt at 80-96 kh/m (50-60 mph) - vehicles equipped with 228 inch wheelbase and 6.8l engine only. *nlm |
|
10/23/01 | NHTSA ID: 622841 TSB ID: 15022 Concerns that the anti-lock brake system (abs) lamp is on with diagnostic trouble codes c1230, c1229, or c1237. |
|
08/08/01 | NHTSA ID: 620447 TSB ID: 14434 Some vehicles may exhibit a buck or jerk (also known as hitching) during highway driving at speeds 40 mph or greater with the cruise control engaged. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
08/07/01 | NHTSA ID: 620409 TSB ID: 14277 Some vehicles may exhibit a rattle noise from the front calipers. |
|
08/07/01 | NHTSA ID: 620421 TSB ID: 14350 Information on vehicles exhibiting a water pump shaft seal leak. |
|
07/24/01 | NHTSA ID: 620294 TSB ID: 14032 Some vehicles with 7.3l dit engines may exhibit loose turbo bolts on the turbo housing. typical symptoms of loose bolts include lack of power and an oil leak. |
|
07/23/01 | NHTSA ID: 620240 TSB ID: 14952 Some vehicles may exhibit early wear of the inner brake pad on the rear disc brakes when operated in mud, slush, dirt, or other severe conditions. |
|
07/20/01 | NHTSA ID: 620208 TSB ID: 14883 Some vehicles equipped with 7.3l engines may exhibit various driveability conditions. |
|
07/20/01 | NHTSA ID: 620218 TSB ID: 14902 Information on vehicles requiring fuel line service. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
07/19/01 | NHTSA ID: 620158 TSB ID: 0195 A condition may exist with lack of power under a load, at cruise or on acceleration may occur on some vehicles built before 11/25/2000 equipped with the 7.3l dit engine. this may be caused by a collapsed air filter element or defective ai |
|
07/19/01 | NHTSA ID: 620166 TSB ID: 011010 Some cuautitlan built vehicles equipped with the 7.3l powerstroke diesel engine with engine sieral number (esn) between 5000000 and 5008850 may exhibit a low oil pressure condition. this may be caused by the rear lifter gallery cup plugs |
|
06/01/01 | NHTSA ID: 619485 TSB ID: 14753 Some vehicles equipped with a 7.3l dit engine may exhibit loose turbo bolts on the turbo housing. |
|
05/30/01 | NHTSA ID: 619419 TSB ID: 0142 Some vehicles may exhibit the engine oil sending unit contacting the oil drip shield attached to the front axle. |
|
05/30/01 | NHTSA ID: 619421 TSB ID: 0144 Fuel quality and moisture in certain diesel fuels may cause some vehicles to exhibit a no start, gradual loss of power, or a rough idle condition due to fuel gelling during extreme cold weather operation. |
|
05/30/01 | NHTSA ID: 619424 TSB ID: 0147 Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
05/30/01 | NHTSA ID: 619426 TSB ID: 0149 Front brake pad or caliper rattle when going over bumps. |
|
05/30/01 | NHTSA ID: 619432 TSB ID: 0153 On some vehicles the trailer tow brake connector c210 (part of wiring loom -14401-) may be hard to find inthe instrument panel. |
|
05/23/01 | NHTSA ID: 619326 TSB ID: 14840 A slight purge of grease from the front hub bearing unit that may be noted between the hub unit and the inboard rotor flange. |
|
05/17/01 | NHTSA ID: 619155 TSB ID: 14652 Some vehicles may exhibit higher than normal steering efforts when the vehicles is at a very low speed or stopped with the brakes applied. |
|
05/17/01 | NHTSA ID: 619161 TSB ID: 14658 Some vehicles equipped with 4r100 transmission and 7.3l engine or with 4r100 6.8l may exhibit engine stall after transmission engagement into reverse and a tip in backout of the throttle. |
|
05/16/01 | NHTSA ID: 619148 TSB ID: 0132 Some vehicles may exhibit stiff steering, wandering, or poor returnability after turns. |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
04/18/01 | NHTSA ID: 618621 TSB ID: 14348 Concerns with a turbo hoot condition. *jb |
|
04/16/01 | NHTSA ID: 618559 TSB ID: 00222 Information regarding power steering pump bolt-correct placement of bolts and washer-windsor built engines. *jb |
|
04/03/01 | NHTSA ID: 617994 TSB ID: 14615 Squeak from the front leaf spring area. *jb |
|
04/03/01 | NHTSA ID: 618067 TSB ID: 0113 Some vehicles equipped with 5.4l or 6.8l engine built through 9/10/2000 may exhibit a miss sound from the exhaust. this may be cuased by the design of the exhaust y-pipe which can cause a miss like sound known as impingement. * |
|
04/02/01 | NHTSA ID: 617924 TSB ID: 14549 Some vehicles equipped with a 7.3l di power stroke engine with an engine serial number between 5000000 and 5008850 may exhibit a low engine oil pressure condition. *jb |
|
04/02/01 | NHTSA ID: 617957 TSB ID: 14570 Concerns with freeplay / steering wander. *jb |
|
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
03/02/01 | NHTSA ID: 616538 TSB ID: 14454 Some vehicles equipped with 7.3l engine may exhibit a no-start or engine stall condition. engineering is investigating. |
|
02/22/02 | Engine | NHTSA ID: 627774 TSB ID: 012113 Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control |
10/22/01 | Engine | NHTSA ID: 622705 TSB ID: 14473 Some vehicles may exhibit diagnostic trouble code p0344 (cam sensor). engineering is investigating. |
02/25/09 | Transmission and Drivetrain | NHTSA ID: 10027988 TSB ID: CSP-08B05 Ford/lincoln/mercury: program of affected vehicles registered in ca (8500 gvwr), ma (6000 gvwr), or vt (6000 gvwr) and who previously paid to have repairs performed that are now covered under federal emissions warranty. 1999-2001 model year |
01/22/08 | Transmission and Drivetrain | NHTSA ID: 10023653 TSB ID: 20052 1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4. *nj |
07/25/07 | Transmission and Drivetrain | NHTSA ID: 10022289 TSB ID: 0721 6.8l engines. powertrain control module (pcm) recalibration. sample consumer letter attached. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
04/29/05 | Transmission and Drivetrain | NHTSA ID: 10014275 TSB ID: 04266 A driveline clunk or bump when starting from a stop. |
04/28/05 | Transmission and Drivetrain | NHTSA ID: 10014086 TSB ID: 042107 General (pcm) power train control module programming procedures. |
04/18/05 | Transmission and Drivetrain | NHTSA ID: 10013402 TSB ID: 04227 Drive away shudder or vibration. *eh |
04/14/05 | Transmission and Drivetrain | NHTSA ID: 10013316 TSB ID: 18376 A cold weather reverse engagement stall. |
04/07/05 | Transmission and Drivetrain | NHTSA ID: 10013110 TSB ID: 04185 Front hubs not engaging, not staying engaged and/or unlocking. |
01/06/05 | Transmission and Drivetrain | NHTSA ID: 10011164 TSB ID: 031603 Rear axle popping/chatter noise - dana 80 model dual rear wheel (drw). *ar |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
08/05/04 | Transmission and Drivetrain | NHTSA ID: 10008574 TSB ID: 17829 Transfer case shift issues on vehicles with an electronic shift on the fly (esof) transfer case. |
10/29/03 | Transmission and Drivetrain | NHTSA ID: 10003748 TSB ID: 03148 New transmission cooler flusher - service tips. 2003 escort and super duty f series included. |
10/08/03 | Transmission and Drivetrain | NHTSA ID: 10003117 TSB ID: 03163 Some vehicles equipped with the dual rear wheel (drw) rear axle may exhibit a tactile popping or audible chattering noise. this popping noise/feel results from the clutch plates and discs (in the limited slip differential case) sticking an |
09/09/03 | Transmission and Drivetrain | NHTSA ID: 10002636 TSB ID: 16925 No engagement or disengagement of hub locks after replacement or service. to include 2000-2003 excursions. |
09/08/03 | Transmission and Drivetrain | NHTSA ID: 10002626 TSB ID: 16915 Excessive drive-away shudder or vibration under moderate to heavy acceleration from a stop. |
07/28/03 | Transmission and Drivetrain | NHTSA ID: 10001951 TSB ID: 16711 Latest calibration release contains upgrades to transmission calibration for reverse clutch operation in manual 1st. *jb |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/26/02 | Transmission and Drivetrain | NHTSA ID: 637471 TSB ID: 15780 Some vehicles may exhibit a front or rear pinion seal leak. |
11/07/02 | Transmission and Drivetrain | NHTSA ID: 636320 TSB ID: 15686 Concerns of diagnostic trouble code p1280 retrived fromthe power train control module (pcm). |
04/19/02 | Transmission and Drivetrain | NHTSA ID: 630626 TSB ID: 0221 Some vehicles equipped with the 6.8l 2v engine 4r100 transmission and pto option may exhibit a low power condition while in reverse gear. |
04/18/02 | Transmission and Drivetrain | NHTSA ID: 630505 TSB ID: 01241 Some vehicles may exhibit a condition of not being able to disengage clutch as the clutch pedal is stroked or the clutch pedal remains on floor. |
04/15/02 | Transmission and Drivetrain | NHTSA ID: 630192 TSB ID: 15292 Some super duty f series equipped with pto capable transmissions may exhibit a failure to go t high idle upon pto engagement. |
04/12/02 | Transmission and Drivetrain | NHTSA ID: 630083 TSB ID: 15550 Subject pertaining to manual transmission shift lever vibration. *yh |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/30/01 | Transmission and Drivetrain | NHTSA ID: 625715 TSB ID: 01181 Brake shift interlock.*jb |
11/08/01 | Transmission and Drivetrain | NHTSA ID: 624626 TSB ID: 15109 A cold weather reverse engagement stall. *yd |
10/23/01 | Transmission and Drivetrain | NHTSA ID: 622819 TSB ID: 15007 Some vehicles equipped with a 4r100 automatic transmission may exhibit a reverse engagement stall. |
09/06/01 | Transmission and Drivetrain | NHTSA ID: 621078 TSB ID: 15076 Some vehicles equipped with 6.8l bi-fuel engines and a pto capable 4r100 transmission may exhibit low power in reverse. |
09/05/01 | Transmission and Drivetrain | NHTSA ID: 620984 TSB ID: 01135 Some vehicles equipped with 4r100 transmission, having a transmission build date between 7/27/2000 and 3/23/2001, may exhibit an intermittent, delayed or no second gear condition. |
07/24/01 | Transmission and Drivetrain | NHTSA ID: 620290 TSB ID: 13992 Information used when configuring the ecs (electronic crash sensor). |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
07/24/01 | Transmission and Drivetrain | NHTSA ID: 620291 TSB ID: 13993 Subject regarding diagnostics and / or mechanical concerns regarding the new venuture transfer case. |
07/20/01 | Transmission and Drivetrain | NHTSA ID: 620201 TSB ID: 14876 Some super duty f series equipped with pto capable transmissions built after 02/01/2001 may exhibit a failure to go to high idle upon pto engagement. |
07/20/01 | Transmission and Drivetrain | NHTSA ID: 620213 TSB ID: 14895 Some 4x4s may exhibit noise, vibration and ratcheting from the front wheel locking hubs that is initiated by road induced bumps or impacts. |
06/01/01 | Transmission and Drivetrain | NHTSA ID: 619481 TSB ID: 14743 Information on rear axle pinion seal part usage. |
05/23/01 | Transmission and Drivetrain | NHTSA ID: 619334 TSB ID: 14857 Certain vehicles equipped with 6.8l bi-fuel engine and a pto capable 4r100 transmission may exhibit a low power in reverse condition. |
05/17/01 | Transmission and Drivetrain | NHTSA ID: 619157 TSB ID: 14684 Information on the revised clutch disc. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
04/18/01 | Transmission and Drivetrain | NHTSA ID: 618625 TSB ID: 14350 Vehicles may experience front shaft seal leakage. *jb |
04/16/01 | Transmission and Drivetrain | NHTSA ID: 618563 TSB ID: 00B53 Vehicles may experience severe vehicle vibration, due to front driveshaft maybe one inch too long. *jb |
04/16/01 | Transmission and Drivetrain | NHTSA ID: 618564 TSB ID: 00B54 Owner notification informing owners that their transmission could be damaged internally and, potentially, could result in a loss of second gear or, ultimately, an inability to move the vehicle if it is driven under certain conditions. |
04/16/01 | Transmission and Drivetrain | NHTSA ID: 618565 TSB ID: 00B54 Owner notification program parts update regarding 4r100 transmission replacement. *jb |
04/02/01 | Transmission and Drivetrain | NHTSA ID: 617901 TSB ID: 14606 Front locking hubs. *jb |
03/05/01 | Transmission and Drivetrain | NHTSA ID: 616522 TSB ID: 002310 Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
12/14/05 | Electrical and Air Conditioning | NHTSA ID: 10018067 TSB ID: 05174 Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode. |
12/05/05 | Electrical and Air Conditioning | NHTSA ID: 10017865 TSB ID: 18735 Headlight adjustment - chassis cab incomplete vehicles. |
05/05/05 | Electrical and Air Conditioning | NHTSA ID: 10014671 TSB ID: 04262 False parking aid warnings. update. |
04/28/05 | Electrical and Air Conditioning | NHTSA ID: 10014083 TSB ID: 042411 Memontary return to idle during aggressive acceleration - diagnostic trouble code (dtc) p0123. |
04/08/05 | Electrical and Air Conditioning | NHTSA ID: 10013113 TSB ID: 02219 Adding additional bulbs to turn indicator or hazard flasher circuits - service tips. |
04/08/05 | Electrical and Air Conditioning | NHTSA ID: 10013116 TSB ID: 04174 Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
01/06/05 | Electrical and Air Conditioning | NHTSA ID: 10011168 TSB ID: 04168 Vacum pump inoperative or runs continuosly - climate control default to defrost. *ar |
07/23/04 | Electrical and Air Conditioning | NHTSA ID: 10008201 TSB ID: 0471 Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. |
07/22/04 | Electrical and Air Conditioning | NHTSA ID: 10008134 TSB ID: 17571 Malfunction indicator lamp (mil) on with diagnostic trouble codes p0603 (powertrain control module keep alive memory error) or p0605 ( powertrain control module read only memory error). |
06/17/04 | Electrical and Air Conditioning | NHTSA ID: 10007395 TSB ID: 17603 Air bag light on with diagnostic trouble code (dtc) b1871 or b1935 following ecs/rcm replacement. |
01/14/04 | Electrical and Air Conditioning | NHTSA ID: 10004886 TSB ID: 03203 Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. |
01/13/04 | Electrical and Air Conditioning | NHTSA ID: 10004879 TSB ID: 16258 Vehicles equipped with a 7.3l engine (after serial number 0661894) - under valve cover (uvc) harness retainer clip released for service. includes 2003 econoline, super duty, f650/750 and excursion. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
01/13/04 | Electrical and Air Conditioning | NHTSA ID: 10004880 TSB ID: 16480 Diagnostic trouble code (dtc) p0340, possible false code. various models including 1994-1996 ford excursion. |
11/14/03 | Electrical and Air Conditioning | NHTSA ID: 10004027 TSB ID: 03181 Remote keyless entry (rke) - service tips. |
07/28/03 | Electrical and Air Conditioning | NHTSA ID: 10001943 TSB ID: 16697 Exhaust air rush noise and lower power. *jb |
12/04/02 | Electrical and Air Conditioning | NHTSA ID: 637689 TSB ID: 15871 Some vehicles may exhibit interference and / or static in the land-mobile radio. |
11/08/02 | Electrical and Air Conditioning | NHTSA ID: 636399 TSB ID: 15757 Subject regarding vehicles exhibiting cold start rolling idle. |
11/07/02 | Electrical and Air Conditioning | NHTSA ID: 636322 TSB ID: 15687 Certain super duty vehicles equipped with lpg engine may exhibit a dead battery condition after leaving the vehicle parked for 2 or 3 days. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/05/02 | Electrical and Air Conditioning | NHTSA ID: 636065 TSB ID: 0245 Information regarding discharged battery charging service tips and guidelines. |
04/16/02 | Electrical and Air Conditioning | NHTSA ID: 630378 TSB ID: 15367 Some vehicles built after 12/4/00 and equipped with a 5.4l or 6.8l engine may exhibit inconsistent speed or surging with the cruise control set at approximately 46, 70, or 92 mph. |
02/22/02 | Electrical and Air Conditioning | NHTSA ID: 627747 TSB ID: 01194 This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. |
02/22/02 | Electrical and Air Conditioning | NHTSA ID: 627760 TSB ID: 01214 Information to aid in diagnosis for clarification of lock-off solenoid and solenoid tank valve coil rsistances for bi-fuel vehicles. |
11/15/01 | Electrical and Air Conditioning | NHTSA ID: 624847 TSB ID: 15141 Some vehicles may experience the seat and seat back may lose its memory position and not latch or lock in the desired position. *yh |
11/01/01 | Electrical and Air Conditioning | NHTSA ID: 624110 TSB ID: 01168 Adding additional bulbs to turn indicator or hazard flasher circuits. *slc |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
10/31/01 | Electrical and Air Conditioning | NHTSA ID: 623944 TSB ID: 01156 Some vehicles may exhibit heater core leaks. *slc |
10/23/01 | Electrical and Air Conditioning | NHTSA ID: 622821 TSB ID: 15008 Some vehicles built after 12/4/00 and equipped with a 5.4l or 6.8l engine may exhibit inconsistent speed or surging with the cruise cotnrol set at approximately 46 or 70 mph. |
10/22/01 | Electrical and Air Conditioning | NHTSA ID: 622697 TSB ID: 15002 On some vehicles, the seat and seat back may lose its memory position and not latch / lock in the desired position. |
08/10/01 | Electrical and Air Conditioning | NHTSA ID: 620482 TSB ID: 14646 Concerns with 7.3l engine starter service. |
08/09/01 | Electrical and Air Conditioning | NHTSA ID: 620480 TSB ID: 14633 Information used when replacing the electronic crash sensor / restraint control module. |
07/20/01 | Electrical and Air Conditioning | NHTSA ID: 620209 TSB ID: 14885 Some vehicles with a 5.4 or 6.8l engine may exhibit slightly inconsistent speed or surging with the cruise control set at approximately 70 miles per hour. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
07/19/01 | Electrical and Air Conditioning | NHTSA ID: 620193 TSB ID: 14646 Subject regarding starter service contact request. |
05/31/01 | Electrical and Air Conditioning | NHTSA ID: 619464 TSB ID: 14776 Some vehicles equipped with 7.3l dit engine and zf-m6hd 6 speed transmission may exhibit a slightly higher idle at cold temperatures. |
04/02/01 | Electrical and Air Conditioning | NHTSA ID: 617913 TSB ID: 14633 Information regarding electronic crash sensor /restraint control module replacement. *jb |
03/02/01 | Electrical and Air Conditioning | NHTSA ID: 616542 TSB ID: 14468 Information on ecs / rcm air bag configuration. |
03/02/01 | Electrical and Air Conditioning | NHTSA ID: 616544 TSB ID: 14471 Some vehicles equipped with less power equipment group, may generate diagnostic trouble code b1302 accessory delay relay coil circuit failure in gem. |
06/25/14 | Other | NHTSA ID: 10055648 TSB ID: ASI-44408 Ford: the restraint control module (rcm) when using vcm ii, would have an error code 35 and diagnostic trouble code (dtc) b1035, and difficulty attempting programmable module installation (pmi). model 2001-2004 f-super duty. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
03/30/09 | Other | NHTSA ID: 10028404 TSB ID: LP-09L02 Ford trucks service campaign: see document search button for owner letter. vehicles have experienced severe steering wheel and front wheel vibrations and oscillations after traveling over a bump or dip in the road. models 2006 f-250/350 su |
04/28/05 | Other | NHTSA ID: 10014138 TSB ID: 042421 Safety belt retraction speed. |
04/18/05 | Other | NHTSA ID: 10013409 TSB ID: 04239 Water leak - roof flange area - water accumulation in headliner and/or leak at the cab floor pan area. |
04/05/05 | Other | NHTSA ID: 10012965 TSB ID: 18406 Service tips before arc welding on the frame or body of a unit. |
09/16/03 | Other | NHTSA ID: 10002759 TSB ID: 16835 Tailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads. |
11/07/02 | Other | NHTSA ID: 636289 TSB ID: 16087 Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes p0740, p0741, p0743, and p1744 (torque converter clutch). |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
11/06/02 | Other | NHTSA ID: 636178 TSB ID: 16170 Some vehicles equipped with a 4r100 transmission and built between january 1, 2001 and may 1, 2002 may exhibit flashing transmission control indicator lamp and any or all torque converter clutch diagnostic trouble codes p0740, p0741, p0743, |
04/15/02 | Other | NHTSA ID: 630181 TSB ID: 15025 Some vehicles may exhibit a squeak and rattle condition. |
04/12/02 | Other | NHTSA ID: 630103 TSB ID: 15566 Some vehicles may exhibit a tacky surface on the instrument panel (ip). |
10/31/01 | Other | NHTSA ID: 623988 TSB ID: 01157 Information regarding transmission fluid usage charts. *slc |
08/09/01 | Other | NHTSA ID: 620460 TSB ID: 14473 Experiencing diagnostic trouble code p0344 (cam sensor). engineering is investigating. |
07/20/01 | Other | NHTSA ID: 620221 TSB ID: 14907 Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. |
NHTSA's feed only includes summaries. For the full text of TSBs:
Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now! |
||
05/31/01 | Other | NHTSA ID: 619446 TSB ID: 01L02 Special field action on certain trucks equipped with 19.5-inch commercial truck tires with steel cord sidewalls - owner's guide supplement and information labels. |
05/23/01 | Other | NHTSA ID: 619304 TSB ID: 14795 Some 2001 vehicles built through 03/14/01 may exhibit a reverse parking aid system inoperative condition. |
04/20/01 | Other | NHTSA ID: 618680 TSB ID: 0008 This fisher service bulletin pertains to the blocker beam on 2001 ford vehicles. |
03/06/01 | Other | NHTSA ID: 616558 TSB ID: 14473 Some vehicles may exhibit diagnostic trouble code(s) p0344 or p0340 (cam sensor). engineering is investigating. |