2004 GMC Envoy GMC Envoy 2004

We are 108,000+ car owners sharing real-world car information.

Join Us

2004 GMC Envoy repairs by problem area

Engine (35%)

Transmission and Drivetrain (2%)

Brakes and Traction Control (3%)

Suspension and Steering (30%)

Electrical and Air Conditioning (27%)

Paint, Rust, Leaks, Rattles, and Trim (3%)

Other (0%)

Select a problem area

Show all problems

Need advice about specific GMC Envoy problems?

Chart based on 66 repairs.
See TSBs and recalls for the 2004 GMC Envoy.

2004 GMC Envoy electrical repair cost distribution

$2500+ (0%)

$1000 - $2499 (0%)

$500 - $999 (28%)

$100 - $499 (39%)

< $100 (33%)

Chart based on 18 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2004 GMC Envoy

Engine not specified

162000 mi

US $600
Dash quit. Top rear window motor, chauffeur window motor, and drivers side window control were bad 
69000 mi

US $450
speedometer worked intermittantly. Replaced entire dash cluster. 

Return to top

2004 GMC Envoy 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic RWD

61000 mi

US $33
Blower Motor Resistor replaced. 
67900 mi left rear door lock actuator replaced 

Return to top

2004 GMC Envoy 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

136632 mi

US $107
AC recharge Owner reported leak in AC system. Dealer tested and found pass side line needs replacing. Dealer estimated cost at $600 prts + $600 lbr. Owner chose not to repair at this time. 
133451 mi

US $250
Dash gauges not working at all 
113000 mi

US $265
return a/c line repaired as previous repair was poorly done. 

Return to top

2004 GMC Envoy 4dr SUV

290-horsepower 5.3L V8 4-speed automatic 4WD w/low range

176000 mi

US $50
Replace front crash sensors (2) Replace instrument panel gage motors 
176900 mi

US $95
Replace tailgate window regulator 
178200 mi

US $500
Replace AC condenser, dryer, expansion valve, compressor, drive belt, evacuate system and recharge 

Return to top

2004 GMC Envoy 4dr SUV

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

40030 mi Had IP Cluster replaced because Speedo stoped working 
78000 mi

US $650
vent came off. water leaked onto floor. put back on. 
52300 mi

US $130
replace left rear back up lamp assembly: socket, lamp and bulb. 
68000 mi

US $400
Instrument cluster stopped working. GMC refused assistance for Envoy, although there is a current recall for the larger trucks. Vehicles must fall under 70K miles to be covered--too low considering the years involved. 
73000 mi

US $85
To dealer for mechanical diagnosis of faulty instrument panel cluster--required by GM in order to qualify for assistance. Assistance declined once again after official diagnosis. Will escalate problem from current status. 
147000 mi

US $600
Fan motor resistor replaced. 

Return to top

See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.

2004 GMC Envoy Electrical Problems

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2004 GMC Envoy problems occur, check out our car reliability stats.