| 1 | 0 | 3 | 4 | 3 | 4 |
GMC Envoy repairs by problem area
Engine (31%)
Transmission and Drivetrain (8%)
Brakes and Traction Control (4%)
Suspension and Steering (24%)
Electrical and Air Conditioning (24%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (5%)
Chart based on 588 repairs.
GMC Envoy other repair cost distribution
$2500+ (0%)
$1000 - $2499 (9%)
$500 - $999 (4%)
$100 - $499 (17%)
< $100 (70%)
Chart based on 23 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2007 GMC Envoy 4dr SUV
291-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 76639 mi US $310 |
Faults related to Stabilitrak system. Dealer found and replaced steering wheel position sensor. |
| 114000 mi | Replaced fuel level sensor under special warranty program GM instituted for this issue. Known problem fuel level sensors in Envoys and Trailblazer wear and fail prematurely. Coverage is 120,000 miles or ten years, only if part fails. |
2006 GMC Envoy 4dr SUV, ext.
291-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 89000 mi | tailgate struts |
2006 GMC Envoy 4dr SUV
291-horsepower 4.2L I6 4-speed automatic RWD
| 61000 mi US $53 |
Tailgate lift supports no longer holding tailgate up. Researched replacement parts on Trailvoy.com. Purchased parts locally, and replaced worn items. Simple task. |
2005 GMC Envoy 4dr SUV, ext.
300-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 140000 mi US $200 |
Replaced washer fluid pumps (front and rear), front was leaking and both were original so did both while it was apart. |
2005 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 128640 mi | Liftgate lock push button stuck in pushed in position. Removed door trim added lubricant and worked in and out until free. |
| 163020 mi | Rear wiper not working. |
| 171740 mi C $500 |
Rear windshield shattered on its own (exploded). |
| 178540 mi | Spare tire would not come down. Safety restraint was rusty and would not release. Followed online instructions and fixed the problem. Cleaned the mechanism, lubricated and tested. Now it should be good for some time. |
2005 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 139660 mi C $87 |
Windsheild wipers would not stop. |
| 141360 mi | Tailgate did not latch sometimes and would not lock. |
| 45000 mi US $1321 |
code p0301 & other repairs needed to correct poor workmanship following code p0301 repair.. |
2003 GMC Envoy 4dr SUV, ext.
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 150000 mi US $400 |
replaced water pump |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic RWD
| 186000 mi US $185 |
Spare tire carrier inoperative- replaced |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 125420 mi | air suspension bag in rear, air compressor motor went out, to expensive to replace right now, fill air bags with inlet in the storage area for jack, I fill to 65 lbs, that will ride for about 2 months, then I have refill |
| 134501 mi US $52 |
removed cluster panel, install new stepper motors, this was a recall items, but mine started acting up after having to many miles for warranty, or extended warranty on this item |
| 154835 mi C $1388 |
Tires worn. Replaced. |
| 141000 mi | Rear glass hatch shocks will need to be replaced soon. |
| 169000 mi US $165 |
I had a leak within the washer fluid reservoir area. Upon inspection found the Headlight washer pump had a crack at the bottom. At $75.00 replacement,I decided to plug the inlet to the pump and stop the leak, never was used anyway. |
2002 GMC Envoy 4dr SUV
270-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 63220 mi | This above the rear wiper spray doesn't work. |
| 362000 mi US $1900 |
ball joints; water pump; thermostat; upper and lower hoses; front struts; rear shocks |
| 109200 mi US $5 |
Repaired driver door check link for noise issue. |
| 126000 mi US $40 |
Replaced driver door check link. Replaced liftglass struts |
| 134000 mi | Broken key cylinder rod clip - replaced. Broken driver door check link - replaced. |
| 33286 mi | Replaced window wiper module |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
