Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 120 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
The AC would “freeze up” and stop blowing cold air. You could hear the fan making lots of noise but almost no air coming from the vents. You could turn the AC off and let the fan blow on high until everything thawed out again (5 to 10 minutes) and then use AC normally... well, until it “froze up” and stopped operating properly.
Did research to determine the Evaporator Coil Tempurature Sensor (thermistor) had failed. Fortunately the dealer was able to test the part to determine it was bad. (Unfortunately it took two trips to the dealer.) Dealer ordered and installed part under warranty. No charge at all.
9500 mi
Software Update
3900 mi
Program the Radio stack
16634 mi
Replaced Evaporator Temperature Sensor, part 97143-C5000 (Thermistor Assy - AC Evap) due to inconsistent cooling of AC system.
26000 mi
Campaign 70C061R1 Evaporator Temperature Sensor Replacement and ECU Update (18-01-010) Part 97143-C5000-QQH
23000 mi
US $42
A/C airflow would become blocked after 3 hours or so on road trip. Hyundai finally listened to many owners with this issue and sent out a Technical Service Bulletin to replace the thermistor (temp sensor) on the evaporator coil inside the cabin. Haven't yet had a chance to test the "fix" on a long trip - hoping the problem is now solved...
42000 mi
US $45
loud slapping noise when fan is turned on Bluetooth is terrible - not sure if it's my phone (I've had several) or the car's Bluetooth technology, but does not recognize the name trying to call, so selects other random names not even closely associated with the name I'm trying to call.
AC stopped after hours driving in 90+ temp in Sept. AC compressors replaced.
35600 mi
US $150
Alternator stopped working, replaced but to play it safe, dealer replaced battery (22 months old) and cost me $150 .
17980 mi
replace compressor
27000 mi
Thumping noise from ventilation system, suspect vaccum flap for recirculation
13640 mi
Head unit started dying intermittently. Head unit replaced once, then tested again, problem determined to be in gauge cluster, dealer said recall coming soon. Will replace gauge cluster under recall.
Brake switch sticking, causing transmission to lock up.
20540 mi
Replace brake switch for second time
16580 mi
Car having trouble starting. Battery replaced.
56000 mi
Ventilation fan squeaked on position 1
65200 mi
US $300
Replaced ignition coils on all 4 cylinders
12000 mi
key chime stays on when key is removed
15000 mi
brake light switch failed.
29080 mi
Gearshift would not go into Reverse or Park, when stopped with engine running. Had to turn engine off and restart. Dealer replaced Brake Switch to correct problem.
26500 mi
Vehicle alarm goes off periodically, when vehicle is unattended, for no apparent reason (at least half a dozen times in last 2 months). Dealer could find nothing wrong with any related systems. Still a mystery.
34720 mi
C $112
Door open light came on/off when driver door slightly pushed/pulled. Door jam was damaged by slamming seatbelt buckle in it causing button to not make full connection. The button was shimmed, which solved problem and previous vehicle alarm activation.
22320 mi
Blower motor was making a chirping sound at low speeds. The blower motor was replaced under warranty.
44640 mi
C $115
Battery (original) was weak and needed replacement.
replaced dome light. $180, covered by extended warranty. Air conditioning broke.
51460 mi
¤70
R/h Pax window cannot be closed by dedicated switch but can be closed by the master switch on the driver's door. Cruise Control When attempting to increase the speed with the cruise control accel switch, cruise control disengages.
28580 mi
HVAC system does not switch change modes - floor, dash, defrost
33980 mi
No volume on radio/CD.
35340 mi
HVAC system does not completely change air flow from floor to front vents. Vent door appears to not be sealing or changing position completely.
52860 mi
Driver side door switch failed causing interior lights to turn on/off intermittently. Door open warning light intermittent.
78740 mi
C $100
When shifting into reverse the backup camera fails to display on dashboard nav system display. Screen goes blank.
26840 mi
A/C fan making noise
127100 mi
C $140
Factory battery died after 10 years
18000 mi
US $55
Steering wheel locked, could not shift car. Bad brake sensor.
Random occurrence of the shifter locking in drive position. Brake/trans sensor replaced to tell the computer the vehicle may be shifted into park. Replaced while waiting on warranty.
50000 mi
AC control panel - AC light became intermittent - AC still worked. m=Module replaced under warranty.
61000 mi
US $408
Door locks and rear hatch lock operated intermittantly/ Lock module needed replacement. Lock parts were ordered incorrectly. Dealer has reordered.
62000 mi
US $400
rear door lock module
4000 mi
The speedometer was reading eractic. The first time they thought it was a fuse. The second time they replace senors. The third time they replace senors and the whole speedomter display digital guages on the dash
63000 mi
Heater fan repair
119000 mi
US $500
Starter solenoid failed. Hyundai OEM starter/solenoid comes as 1 unit so I was forced to replace the entire starter. Repairs took 1 day.
3000 mi
The power cable that runs from passenger side window switch to window lift motor had come loose from the motor; was re-connected by dlr tech, and good to go, in 20 mins.
33000 mi
Radio and Navigation system had no audio.
19000 mi
Tech found climate control blower motor bearing bad. Ordered new part. climate control blower motor replaced. problem resolved.
40000 mi
Replaced noisy blower motor.
52500 mi
US $195
Battery was completely dead and not chargeable. Upon inspection, it was found the dealer had installed the auto-dimming mirror incorrectly, putting a constant draw on the system.
Lost all audio, have to replace NAV radio. Not covered by Hyundai Canada since warrantied to 60k. Dealer acquired refurbished unit for $300. and agreed to absorb the cost. Problem occurred about 3 or 4 months ago but thought it my action.
52080 mi
Initial audio problem was fixed, radio replaced with refurbished unit which also had problems and was replaced by the dealer without charge. No problem since.
42000 mi
HVAC fan motor bearing was making noise at the 2 lowest setting. The fan motor was replaced.
Aircon fault caused the wires to burn and housing under the dash to melt. Something to do with a pipe that meed to be flushed during service. becomes blocked causing aircon breakdown and water leakage into passenger well
56000 mi
US $250
Battery died. I replaced it and the alternator, which died a week later so i had to turn it in under warrantee and install another one. All works great now.
56000 mi
US $800
Replaced compressor, 7 days later new compressor seized up, after spending 200 more they replaced it and it has been working good since.
41540 mi
A $450
Broken wire between switch and air con. The local agent for Hyundai claimed it was the ECU which needed to be replaced at very big bucks but three auto electricians later the broken wire was found, repaired and no trouble since, for a very modest sum.
47740 mi
rt. side traffic indicators operating very quickly. replaced rear indicator light socket.
heating problems wouldn't heat up & heated seats stopped working, engine warning light comes on and off, with apparently no engine problem, signal switches / lights stopped working
11000 mi
Engine had belt/bearing squeal except when hot; dealer replaced serpentine belt and generator, solved problem. Replaced alternator and belt to stop squeeling/chirping
31000 mi
Drains battery intermittently when parked, disabling vehicle until jumped. Dealer attempted to find problem, could not.
Drove OK but MIL light on, codes P0700 $11 Transmission Control System, P0741 $18 Torque Converter Clutch Circuit Perf/Stuck Off. Seems related to TSB-09-AT-018, which would be bad. Replaced battery and ATF, & problem hasn't recurred so far.
Remote key locking but not unlocking the car. The unlock relay and master switch on the driver's side were replaced
8000 mi
speedometer does not work at startup. Only occurs occassionally and starts working after a few miles and and a slow down speed up occurs. Could not find anything on through a computer check. Dealer said to come back in if problem occurred again.
12000 mi
Speedometer was not working correctly. A new cluster was ordered and replaced. Unit is now working fine. Installed new speedometer.
189000 mi
US $180
Air conditioning would start out cold and blow warm after a short time.
TPMS light for malfunction system (not for low pressure). Dealer claimed problem was wheel sensor in left-rear wheel. Replaced under warranty and light in dash was off. The very next day the TPMS light came on again.
37000 mi
Dealer must have deleted one of the original 3 TPMS sensors when adding the replaced TPMS sensor on the first trip. All TPMS reprogrammed and working correctly.
108000 mi
US $35
Rear defroster/heated mirrors not working. Blows fuse. Switch replaced, rear window contacts cleaned. Still blows fuse. Repair was not successful.
110000 mi
Rear defroster / heated mirrors electrical problem never fixed.
84000 mi
Blend door actuator clicks and blower door does not open to let air come thru top vents. Fourth time this has been replaced, whenever I switch back in the spring from hot to cold.
Automatic climate control display changed from Fahrenheit to Celsius and remained this way until dealer changed setting back to Fahrenheit. Only lead technician knew how change this setting, so had to return to dealer a later time.
15000 mi
Cassette Player completely broken. Replaced headunit.
16000 mi
Radio screen was flickering, needed replacement. Radio screen was broken/flickering.
26000 mi
Traction control warning was illuminated, resolution was to replace the brake switch which was/is soon to be a recall (but had not been mailed out yet).
79660 mi
C $300
cannot get cruse to work
95640 mi
C $600
Don't remember
58000 mi
Heat/A-C system wasn't working further diagnosis and another part ordered finally fixed
See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how
frequently Hyundai Tucson problems occur, check out our car reliability stats.