2007 Ford Expedition Ford Expedition 2007

We are 106,000+ car owners sharing real-world car information.

Join Us

2007 Ford Expedition repairs by problem area

Engine (21%)

Transmission and Drivetrain (15%)

Brakes and Traction Control (13%)

Suspension and Steering (10%)

Electrical and Air Conditioning (26%)

Paint, Rust, Leaks, Rattles, and Trim (10%)

Other (5%)

Chart based on 100 repairs.

2007 Ford Expedition engine repair cost distribution

$2500+ (9%)

$1000 - $2499 (27%)

$500 - $999 (36%)

$100 - $499 (18%)

< $100 (9%)

Chart based on 11 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2007 Ford Expedition 4dr SUV, ext.

300-horsepower 5.4L V8 6-speed automatic 4WD w/low range

78000 mi

US $80
Due to two piece spark plug design, the bottom but of the spark plug gets stuck and breaks off. Used special tool to remove three broken spark plugs. 
142600 mi

C $1000
Replaced throttle body assembly due to rough idling (chugging) Throttle body assembly did not solve poor idle. Variable Cam Timing (VCT) solenoids replaced 
145700 mi Engine seizure 
134300 mi

US $2800
Radiator leaking at transmission coolant lines and other places. Radiator replaced. 
152000 mi

US $1600
New fuel pump needed 
99000 mi

US $920
Replaced failed fuel pump. Had to tow truck to shop. 
108000 mi

US $500
Spark Plugs 

Return to top

2007 Ford Expedition 4dr SUV

300-horsepower 5.4L V8 6-speed automatic RWD

82000 mi Cylinder #4 misfire CEL past 1 month from failed coil packs and/or spark plugs gone bad. Misfire CEL identified by scanning diagnostic tool. I've decided to just replace all 8 coil packs & spark plugs at the same time. 
98000 mi

US $670
replace coil on one cylinder not firing 
158000 mi

US $980
Coil on Cylinder #5 failed. Check on all other coils revealed three other potential problematic. Chose to replace all eight coils duel to mileage. Also had front brake pads replaced. 
124000 mi

US $380
sputter when maintaining speed. 
83000 mi

US $1200
no start replaced fuel pump and spark plugs 

Return to top

2007 Ford Expedition 4dr SUV

300-horsepower 5.4L V8 6-speed automatic 4WD w/low range

33000 mi Transmission reflashed to fix 2-1 gear downshifting issue. 
59500 mi

US $200
Developed a miss and check engine light. Turned out to be bad coil pack on # 5 cylinder. 
115000 mi

US $200
Check engine light came on. 1st trip to repair-no trouble found. Check engine light on again. miss detected upon light acceleration. Code showed misfire. replaced #2 coil pack. checks ok now. 
130000 mi

US $340
Whining sound from engine compartment rising and falling in pitch in step with RPM's. Shop replaced serpentine belt, pulley, idler, Tensioner (?). 
93000 mi

US $1700
oil leaks. replaced 1) valve cover gasket 2) oil pan gasket 3) oil filter gasket 
146000 mi

US $288
replaced belt tensioner 
84000 mi

US $1800
Serpentine belt cracked and replaced. Corroded wire noted when spark plugs were replaced causing misfire on cylinder number 4. Wire replaced. 

Return to top

2007 Ford Expedition Engine Problems

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2007 Ford Expedition problems occur, check out our car reliability stats.