| 1 | 0 | 3 | 4 | 3 | 4 |
2002 GMC Envoy repairs by problem area
Engine (31%)
Transmission and Drivetrain (8%)
Brakes and Traction Control (3%)
Suspension and Steering (19%)
Electrical and Air Conditioning (26%)
Paint, Rust, Leaks, Rattles, and Trim (7%)
Other (7%)
Chart based on 118 repairs.
2002 GMC Envoy repair cost distribution
$2500+ (1%)
$1000 - $2499 (13%)
$500 - $999 (13%)
$100 - $499 (24%)
< $100 (48%)
Chart based on 91 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 GMC Envoy
Engine not specified
| GMC Envoy in Ohio, United States Oct 2007 - Mar 2010 | |||
| Nov 200734000 mi | There was a squeak in the engine compartment at cold (below freezing) temperatures which could not be duplicated at the dealership. | ||
2002 GMC Envoy 4dr SUV, ext.
270-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| GMC Envoy in Arizona, United States Dec 2011 - Mar 2014 | |||
| Mar 2012140000 miUS $2251 | Rear seating area heater core leaking. Removed and replaced. Airbags warning light was on all the time. Sensor had gone bad. Panel that holds driver's seat controls broken. | ||
| Apr 2012140000 mi | Motor in console attempted to move rear-seat vent door--cycled making clicking sound. Mechanic disconnected motor. | ||
| Mar 2013146000 miUS $90 | Windshield washer pump failed. | ||
| Jan 2014141000 miUS $433 | Power steering pump. | ||
2002 GMC Envoy 4dr SUV
270-horsepower 4.2L I6 4-speed automatic RWD
| GMC Envoy in Florida, United States Feb 2012 - Mar 2012 | |||
| Mar 2012213000 miUS $100 | Cost was to diagnose A/C issue that was going to be approx $1500 to repair. At the same time, they found an issue with the water pump. Total repair was to be over $2000. Had put over $1000 into repairs in the prior 30 days; time to sell. | ||
| GMC Envoy in Texas, United States Oct 2009 - Dec 2013 | |||
| Dec 2010101000 miUS $55 | minor radiator leak - fixed with Bar's Leaks sealant | ||
| Jun 2011106000 miUS $270 | ignition coil failure. | ||
| Jun 2012114000 miUS $400 | Replaced water pump | ||
| Jun 2013124000 miUS $400 | shifter cable replacement (broke, could not shift) and electrical short diagnosis. latter due to faulty aftermarket subwoofer installation. | ||
| GMC Envoy in Texas, United States Jun 2007 - Dec 2009 | |||
| Jul 2008151000 miUS $650 | Air suspension leaked down overnight. | ||
| Mar 2009165000 miUS $675 | Replace ball joints and front stabilizer links. | ||
| Nov 2009177000 miUS $350 | engine stalled repeatedly | ||
2002 GMC Envoy 4dr SUV
270-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| GMC Envoy in Washington, United States Feb 2012 - Jun 2013 | |||
| Jun 2013168000 mi | AC compressor failure | ||
| GMC Envoy in Maine, United States Sep 2012 - Dec 2012 | |||
| Sep 2012120000 miUS $900 | Replace AC compressor; recharge system. | ||
| Oct 2012120700 miUS $2600 | Replace transmission | ||
| Nov 2012121100 miUS $195 | Passenger side rear on the frame in front of the wheel the mount rusted through. Would not pass inspection. Dealer and collision shop refused to take it on. Found a welder/fabricator who said it was a "piece of cake"; did it in 1 day. | ||
| GMC Envoy in Michigan, United States Sep 2012 - Oct 2012 | |||
| Oct 2012210000 miUS $325 | ignition coil failed | ||
| GMC Envoy in Oregon, United States Oct 2001 - Feb 2019 | |||
| Nov 2001122 mi | Front windsheild water leak, re-sealed windshield | ||
| Jun 20027183 mi | Replaced 4WD selector switch | ||
| Oct 20027183 mi | Reprogrammed onstar module | ||
| Oct 200433286 mi | Replaced window wiper module Fan clutch replaced under warranty | ||
| Aug 2010104410 miUS $154 | Outside ambient air temp sensor replaced | ||
| Mar 2011114330 miUS $700 | Replace front struts, mounting brackets, heavy duty shock absorbers, strut mounts | ||
| Sep 2011122963 miUS $543 | Replaced front and rear sway bars with after-market (stiffer) sway bars | ||
| Jul 2012140754 miUS $888 | Replaced front inner and outer axle CV joint boots | ||
| Jan 2013151447 miUS $3230 | Replace engine mounts and transmission mount. Replace front suspension lower control arms and bushings | ||
| May 2013154808 miUS $423 | Replace brake master cylinder & bleed hydraulic system | ||
| Feb 2014164186 miUS $306 | Serpentine Belt Idler Pulley Serpentine Belt Tensioner | ||
| May 2014167700 miUS $800 | Replaced water pump and thermostat | ||
| Aug 2014170181 miUS $371 | 6x ignition coil replacement due to misfire in #4 / lifespan of component Replaced L Front Axle Shaft Assembly | ||
| Oct 2015179000 mi | Recall on vehicle indicator lights. I had experienced intermittent failures of the left tail light for several years, and was surprised to find that a recall had been issued by GM many years ago. | ||
| Feb 2016181295 miUS $633 | RF outer tie rod loose, replaced. L brake light inoperable since recall repair 3 mos ago. Removed and checked bulbs, Cleaned contacts, light now working. Removed rear brake rotors and adjusted brake shoes (handbrake) Replaced front brake pads and machined rotors RF outer tie rod loose, replaced. | ||
| Sep 2016187000 miUS $879 | Wheel bearings replaced + alignment | ||
| Feb 2017189000 miUS $456 | Starter replaced | ||
| GMC Envoy in New Jersey, United States Dec 2015 - Jan 2016 | |||
| Jan 2016 | 4 wheel alignment, radiator replacement. | ||
| GMC Envoy in British Columbia, Canada Feb 2015 - Sep 2016 | |||
| May 2015193440 miC $20 | replaced front sway bar bushings | ||
| GMC Envoy in Florida, United States Feb 2015 - Jul 2015 | |||
| Jul 2015212000 miUS $225 | When parked for a couple of days, would not start up. New battery took care of the problem. | ||
| GMC Envoy in Oregon, United States Jan 2011 - Mar 2012 | |||
| Jan 201297000 miUS $87 | Misfire on #1 cyl. Replaced Spark Plugs first. Replaced coil pack for #1 cylinder to fix problem | ||
| GMC Envoy in Texas, United States Aug 2013 - Feb 2016 | |||
| Feb 2016179000 mi | The airconditioning system was leaking freon in a couple of different places. | ||
| GMC Envoy in Alberta, Canada Dec 2010 - Mar 2017 | |||
| Aug 201151240 miC $1600 | Howling noise, was rear differential bearing I was told. Had purchased aftermarket warranty - the shop had to talk with the warranty place and argue over it, thereby delaying repair. Warning light with wrench and oil can/truck icon stays on for a few seconds upon starting up after all the other test lights show and go off, but this light goes away after a few seconds. | ||
| Jan 201250720 miC $2400 | ball joints worn out already. Rear Differential needed replacing | ||
| Dec 201257040 miC $100 | Turn Lamp in the left front bumper came loose and sitting inside of the bumper cowling. Muffler starting to rattle when idling. | ||
| Mar 201361380 mi | Drivers side plastic lower seat cowling (where it wraps around the bottom seat cushion), the plastic cowling where the switches are to move the seat forward and back, and tilt, has broken away. | ||
| Apr 201361480 mi | Rear Wiper spray control doesn't work. Wipers work, but not the spray part when depressing the button. | ||
| Aug 201362000 mi | Check engine oil light (oil can icon) comes on upon starting, then goes away after 30 seconds. Oil levels well. | ||
| Apr 201563220 mi | Just after I finished a survey the Envoy was doing well, I noticed steering fluid on my garage floor. Yep, 100,000KM (60,000miles) and PS needs work. This above the rear wiper spray doesn't work. And rear axle needed changing. | ||
| Jul 201566540 miC $300 | Curved pipe on the end of the Muffler fell off on highway, now sounds like a V8 4 barrel | ||
| Dec 201568200 miC $1100 | Clutch fan went. Sounded like it was stuck in low gear, and hard to shift. Thought it was tranny, but the clutch fan was loud. Took 3 hours book time to replace something that should be <1 hour. Cost 1,000 | ||
| GMC Envoy in Pennsylvania, United States Sep 2007 - Feb 2012 | |||
| Jun 200851000 miUS $635 | #1 cylinder misfiring causing rough engine idling. Ignition coil replaced. Rear stabilizer bars needed replaced or vehicle would not have passed inspection. | ||
| Aug 200853000 miUS $1200 | More bad ignition coils needed to be replaced. Vehicle accelerated poorly and seemed underpowered, then Service Engine Light came on. Also found bad plugs and a melted wire. The shop then found a leaky seal and replaced it. Replaced to worn front stabilizer bar. | ||
| May 201184700 miUS $750 | Heard a squeaky noise underneath the car. Dealer diagnosed a bad lower control arm bushing. Part replaced and repair successful. No further noises noted, car runs and drives fine. | ||
| GMC Envoy in New Jersey, United States Jul 2007 - May 2011 | |||
| Sep 200752000 miUS $175 | The fan switch would only turn on the fan at speeds 4-.5 | ||
| Feb 201190000 miUS $550 | Check engine light was coming on. Car diagnosed with multiple engine misfires. Replaced cam sensor. | ||
| Mar 201192000 miUS $550 | Car continued to miss. Determination was a coil, after substantial testing. Coil replaced. | ||
| Apr 201192000 mi | Misfiring again three weeks later, replaced another coil. | ||
| GMC Envoy in Washington, United States Aug 2007 - Jun 2011 | |||
| Sep 2010118000 miUS $1000 | Blown head - needed the entire engine rebuilt. We sold it to a friend who had it repaired and is now driving it. | ||
| GMC Envoy in New Jersey, United States Jul 2008 - Dec 2010 | |||
| Aug 200870000 miUS $300 | Replaced alternator. | ||
| GMC Envoy in California, United States Dec 2009 - Mar 2012 | |||
| Jul 2010297700 miUS $560 | Believed problem to be PS Actuator per panel discussion of hot air through passenger vents with AC on. Problem was actually temperature actuator, which has never been discussed. Problem none-the-less resolved. | ||
| Dec 2010360000 miUS $900 | Cylinder #1 not firing. Wires and plugs replaced. Throttle body badly worn, replaced rather than clean. | ||
| May 2011362000 miUS $1900 | Water pump; hoses, serpentine belt; shocks (4); ball joints; CV boots. All replaced. ball joints; water pump; thermostat; upper and lower hoses; front struts; rear shocks | ||
| Aug 2011362000 miUS $1800 | Gear on axle in front transfer case froze bending shaft and breaking bearing loose. Replacement bearing located and axle rapaired. Air conditioning switch leaking and would shut down. System evacuated; dye tested; switch replaced; system charged. | ||
| GMC Envoy in Illinois, United States Sep 2009 - Sep 2011 | |||
| Nov 2009127000 miUS $445 | Left suspension air bag had a leak in it, had to be replaced. I now suspect the right side has a very tiny leak in it also. | ||
| GMC Envoy in Michigan, United States May 2010 - Dec 2010 | |||
| Nov 2010203000 miUS $366 | MAP sensor, fuel induction cleaning, reprogram PCM | ||
| Dec 2010203000 mi | Lifter noise, engine seals/ gaskets starting to leak, transfer case issues - maybe the sequencing switch? Rusting at bottom of lift gate and doors - seems to be starting on the inside of the exterior skin and at the seam between the exterior skin and liner panel. Electrical problem caused by lift gate - maybe a short?, drivers side and review mirror (interior) auto-dimming mode not functioning, drivers side mirror no defroster, ground issue (maybe) that causes static on the AM radio. | ||
| GMC Envoy in Michigan, United States Jan 2010 - Apr 2021 | |||
| Mar 201091000 miUS $3 | Driver's side temperature door actuator inoperative. | ||
| May 201092000 miUS $50 | Replaced rear stabilizer bar end links due to rattle. | ||
| Jan 201198000 miUS $75 | Replaced R/F wheel bearing. | ||
| May 2011102000 miUS $45 | Replaced rear sway bar bracket Replaced switches/knobs with chipped paint | ||
| Jun 2011102000 miUS $35 | Outside Ait Temperature Sensor Replaced Underhood lamp replaced | ||
| Jan 2012107000 miUS $78 | Replaced ignition coil on cylinder #3. | ||
| Mar 2012109000 miUS $37 | Replaced both outer tie rod ends | ||
| Apr 2012109200 miUS $5 | Repaired driver door check link for noise issue. | ||
| Jun 2013120000 miUS $65 | Replaced oil pressure sender Replaced front passenger window regulator assy. | ||
| Sep 2013122000 miUS $134 | P1440 code set - Evap System Fauly | ||
| Oct 2013122300 miUS $440 | Replaced both front upper and lower control arms, ball joints, and bushings, and both inner tie rods. | ||
| Mar 2014126000 miUS $40 | Replaced driver door check link. Replaced liftglass struts | ||
| Sep 2014131000 miUS $304 | Replaced cat-back exhaust system. | ||
| Nov 2014132000 miUS $160 | Replaced rear wiper motor. | ||
| May 2015134000 mi | Broken key cylinder rod clip - replaced. Broken driver door check link - replaced. | ||
| Jun 2015135000 miUS $244 | AC Compressor Replacement | ||
| Jun 2016140000 miUS $52 | Leaking gas. Replaced fuel pump module, fuel filter | ||
| GMC Envoy in North Carolina, United States Mar 2011 - Jan 2017 | |||
| Jun 2015118000 miUS $198 | External temp sensor went crazy making the A/C not function correctly Sensor replaced and all is well again. | ||
| Jan 2016115300 miUS $1100 | Right rear level sensor and both rear air springs had given up the ghost with all these miles and were replaced so that the air suspension works correctly again. | ||
| May 2016122000 miUS $1358 | Replace inoperative passenger side door actuator for passenger side A/C. Leaking A/C switch Replaced engine belt and tensioner | ||
| Aug 2016124000 mi | Leaking gas tank, discovered during the May 2016 visit to the service department, was replaced by GM on August 29, 2016. Will be picking up the vehicle this morning, August 30 from the dealer shop. Replaced Fuel Level Sensor after the replacement of the fuel cell. Existing sensor was corroded and replaced by the dealer at no cost to me. | ||
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
