| 1 | 0 | 3 | 4 | 3 | 4 |
2011 Ford F-250+ Super Duty repairs by problem area
Engine (40%)
Transmission and Drivetrain (4%)
Brakes and Traction Control (8%)
Suspension and Steering (12%)
Electrical and Air Conditioning (36%)
Paint, Rust, Leaks, Rattles, and Trim (0%)
Other (0%)
Chart based on 25 repairs.
2011 Ford F-250+ Super Duty repair cost distribution
$2500+ (5%)
$1000 - $2499 (19%)
$500 - $999 (10%)
$100 - $499 (29%)
< $100 (38%)
Chart based on 21 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2011 Ford F-250+ Super Duty
Engine not specified
| Ford in Ontario, Canada Sep 2015 - Sep 2015 | |||
| Sep 201523560 mi | Exhaust sensor set burn too lean to run. | ||
| Ford in Ohio, United States Dec 2015 - Nov 2016 | |||
| Mar 201688000 mi | main AC line worn through, not holding refrigerant, replace line, recharge system. Alternator getting too hot causing regulator in rear of housing to short/fail in some way, ALT light in dash was on, dealer pulled codes. the vacuum system that actuates the auto 4x4 engagement was not working in the front wheels, could manually lock hubs but the auto engagement was failing. Dealer diagnosed the problem and reconnected. | ||
| Aug 201691000 miUS $100 | Alternator issue returned from before, traced to wiring harness problem, defective connector, connector replaced wiring harness repaired. | ||
2011 Ford F-250+ Super Duty 4-door
turbocharged 8-cylinder diesel automatic 4WD
| Ford in California, United States Jun 2015 - Jun 2022 | |||
| Sep 202151000 miUS $400 | Dashboard error stated DEF fluid issue even though tank was full. Pulled the code and found it was a common failure for the DEF tank heater coil / sensor unit. Pulled the tank down and replaced the part. | ||
| May 202258000 miUS $600 | Emissions: DEF Tank leaking. Replaced pump, gasket, and heater coil assembly. | ||
| Ford in New York, United States Jun 2015 - Jul 2022 | |||
| Nov 201761500 miUS $150 | Replaced starter. | ||
| Dec 201762000 mi | Ford warranty repair on emissions sensor. | ||
| Nov 202088000 miUS $500 | Replaced both front wheel brarings | ||
| Nov 202194000 miUS $200 | Replace rear brake backing plates due to rust. Northeast road salt. | ||
| Jun 202297000 miUS $100 | Replace Turbo intake pipe. Cracked while under load. Typical failure, but simple repair. | ||
| Jul 202297500 miUS $12 | Quick recharge, less than one can. Quick and easy, port easily accessible under hood near firewall. | ||
| Ford in New Mexico, United States Jun 2021 - Jun 2022 | |||
| Jul 2021180000 miUS $5000 | Replace Turbo | ||
| Ford in Minnesota, United States Jun 2015 - Jun 2022 | |||
| Nov 201644800 mi | Heater for the DEF fluid. Sensor probe in exhaust | ||
| Jun 202287000 mi | DEF system | ||
2011 Ford F-250+ Super Duty 4-door
turbocharged 6-cylinder automatic 4WD
| Ford in Alberta, Canada Jun 2015 - May 2017 | |||
| Apr 2016119040 miC $1007 | Replaced both batteries, violet wire to alternator found burnt fuse-able link and replaced. | ||
2011 Ford F-250+ Super Duty 4-door
8-cylinder automatic 4WD
| Ford in Saskatchewan, Canada Jul 2015 - Jan 2022 | |||
| May 201885560 miC $1100 | stuck brake calipers, worn rotors (from calipers not releasing<<0 | ||
| Ford in Oregon, United States Jun 2015 - Aug 2017 | |||
| Mar 2017136000 miUS $80 | Replaced evap canister - clogged due to dust/dirt | ||
| Ford in Minnesota, United States Mar 2017 - Dec 2021 | |||
| Feb 2018200000 miUS $1000 | Condenser seized up - replaced | ||
| Nov 2021220000 miUS $1600 | loose steering | ||
| Ford in Alberta, Canada Oct 2017 - Jun 2018 | |||
| Nov 201747740 mi | Would only take a few liters of gas, then pump would click off, then a few more liters, etc... | ||
| Dec 201748980 mi | Truck was turning over slowly and needed to boost. Tested battery and it failed. Replaced battery myself. | ||
| Mar 201850220 miC $73 | Power steering pressure hose developed a leak. Replaced pressure hose myself. | ||
2011 Ford F-250+ Super Duty 4-door
8-cylinder automatic 2WD
| Ford in Florida, United States Jun 2015 - May 2017 | |||
| Jun 201560000 miUS $425 | Evaporater | ||
See TrueDelta's information for all Ford models.
