| 1 | 0 | 3 | 4 | 3 | 4 |
2004 Ford Expedition repairs by problem area
Engine (23%)
Transmission and Drivetrain (19%)
Brakes and Traction Control (6%)
Suspension and Steering (18%)
Electrical and Air Conditioning (27%)
Paint, Rust, Leaks, Rattles, and Trim (6%)
Other (1%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 83 repairs.
2004 Ford Expedition electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (0%)
$500 - $999 (10%)
$100 - $499 (67%)
< $100 (24%)
Chart based on 21 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 Ford Expedition
Engine not specified
| 161000 mi US $300 |
Battery light came on, turned out I needed an alternator. |
2004 Ford Expedition 4dr SUV
260-horsepower 5.4L V8 4-speed automatic RWD
| 102300 mi | Backup sensors do not work so I wanted to replace one to resolve the issue. The codes for all 4 backup sensors are coming up and the mechanic is unclear on how to proceed to further diagnose the issue. |
| 75000 mi US $20 |
HVAC air duct valves were malfunctioning due to vacuum leaks in vacuum hoses from engine. Repairs partially resolved problem. Apparently there are additional vacuum leaks that have not been isolated. |
| 63700 mi | When we bought the vehicle, the airbag light was on. The dealership ordered a new sensor and paid to have it installed. |
| 180000 mi | Replaced right headlight. |
2004 Ford Expedition 4dr SUV
260-horsepower 5.4L V8 4-speed automatic 4WD w/low range
| 150600 mi US $225 |
Alternator went bad Drivers window regulator bad |
| 52000 mi US $249 |
Airbag light comes on due to some malfunction in the passenger side front seatbelt. Replaced unit with labor. |
| 57994 mi US $175 |
replace aux. mode door actuator motor |
| 52700 mi | generator replaced in September 2009 on extended warranty, now again defect, replaced on parts warranty |
| 95000 mi US $225 |
truck has a power drain but no codes replaced altinator now has code, check charging system had it checked and all reads fine. |
| 203700 mi US $150 |
alternator failed |
| 117800 mi C $500 |
Air bag crash sensor located in front bumper failed due to corrosion. Sensor and electrical connector replaced. |
| 89000 mi US $100 |
Replaced battery |
| 122000 mi US $638 |
Charging System Warning came on battery was draining |
| 139000 mi US $275 |
Driver side window failed in an open state Window failed to close again. System fixed, then failed again. Symptoms include: Loud whining sound from mechanism when lowered in temperatures under 20F and wind noise from seal in upper rear corner of same driver window. Usually returns within a week. |
| 85000 mi US $170 |
Blower only worked on "high" setting, replaced a rheostat |
| 100300 mi US $160 |
No cool air, turned out to be blown A/C clutch fuse |
| 121000 mi US $225 |
Heat blower would only work on "high/Max". Replaced Blower Motor Resistor. |
2004 Ford Expedition 4dr SUV
232-horsepower 4.6L V8 4-speed automatic RWD
| 50000 mi | navigation system replaced also warranty |
2004 Ford Expedition 4dr SUV
232-horsepower 4.6L V8 4-speed automatic 4WD w/low range
| 149200 mi US $270 |
system needed recharge and repair to compressor electrical connection |
See TrueDelta's information for all SUVs
See TrueDelta's information for all Ford models.
